Professional Documents
Culture Documents
Buggy Plan
Buggy Plan
I copied this site but I don't remember where from. Thanx to the designer of this
plan.
The buggy.
The buggy looks a lot alike the peter Lynn Classic
1.3x Wide buggy wheel from the kite shop (ready) or the pvc wheel of a barrow
(needs some work to fit bearings) from the hardware store.
2.Rear-axle:1x 950 mm tube dia. 32x2 mm,2x 30 mm rod dia. 28 mm, full,2x Bolt
M12 - 100 mm with spring-ring,2x 90 mm tube dia. 30x2 mm.
4.Frame Tube's: 2x 780 mm tube dia. 25x1.5 mm,2x sheet 100x70x4 1x Bolt M8 - 55
mm with 1x M8 nut and spring-ring.
5.Front Fork: 1x 850 mm tube dia. 25x3 mm,1x sheet 220x25x4 mm,2x 37 mm tube
16x2 mm,2x 260 mm tube dia. 16x1.5 mm,1x Bolt M8 - 125 mm with 1x M8 nut,1x
Bolt M12 - 180 mm with 2x spring-rings and 1x M12 nut.2x ballbearings 8x32x12.
Stainless and seawater-resistent and sand-resistent !!!
6.Bending tool, Welding tool for stainless steel, powered polish tools.
Building the
1.Rear-axle:
I don't know if the tube-in-tube connector on the rear-axle is strong enough. Maybe
it needs side-support on each side of the connectors. The tube-in-tube connection
(foto) with the frame-tube has a 1 mm tolerance between the tubes.
2.Balhead (downtube):
The square tube must be at least 2 mm thick. For many wheelies and Big Foot
TIRES, 1.5 mm is to WEAK !!. The big X diameter, in the drawing, is the outside
diameter of the ballbearing. Head and bearing MUST form a light press fitting.