Professional Documents
Culture Documents
RAN1308: HSUPA Interference Cancellation Receiver
RAN1308: HSUPA Interference Cancellation Receiver
Single RAN, Rel. SRAN 17A, Operating Documentation, Issue 05 (HTML) > Features > WCDMA Features > Features from
Previous Releases > RU30 Feature Descriptions and Instructions > Radio resource management features
RAN1308 Benefits
End-user benefits
This feature benefits the end user as follows:
higher HSUPA throughput possible in a typical mixed data and voice scenario with 2 ms TTI HSUPA user
high Ec/No for a high data rate 2 ms TTI HSUPA user possible, while keeping the noise rise within the planned limits
Operator benefits
This feature benefits the operator as follows:
balanced downlink/uplink cell capacity without the need for 4 Rx antennas
improved coverage, for example, for AMR calls existing in parallel with peak rate E-DCH transmissions
localhost:5423/informationbrowser/index.jsp?topic=%2Fm214044344_html%2Fhtm%2Fdocs%2Fru30_feature_descriptions_and_intructions%2Ffd_ran1702_freq_domain_equalizer-0900d80580a1d1f… 1/12
2/28/2021 RAN1308: HSUPA Interference Cancellation Receiver
Non-IC users:
all 10 ms TTI E-DCH users, and all DCH users
benefit from reduced interference
Interference cancellation is a non-linear detection method within the more general class of multi-user detection algorithms.
The antenna signal is first received with a rake receiver or with a frequency-domain equalization (FDE) technique. Turbo decoding is performed to obtain the
E-DCH with 2 ms TTI signals. The decoded data is used to reconstruct the original 2 ms TTI signals, which constitute interference for other users.
Reconstruction includes turbo encoding, spreading, and modulation. Finally, the reconstructed signals (that is, the interference for the other UE) are
summed up and subtracted from the original antenna signal—non-IC users’ signal (residual signal) is derived this way. After that, all other users’ (non-IC
users) signals are demodulated on the residual signal. As a result, all other users’ signals (which have been received from the residual signal) benefit from a
lower interference level. This improves coverage and capacity for the cell.
localhost:5423/informationbrowser/index.jsp?topic=%2Fm214044344_html%2Fhtm%2Fdocs%2Fru30_feature_descriptions_and_intructions%2Ffd_ran1702_freq_domain_equalizer-0900d80580a1d1f… 2/12
2/28/2021 RAN1308: HSUPA Interference Cancellation Receiver
The RAN1308: HSUPA Interference Cancellation Receiver feature is based on the assumption that there is no (or very little at most) real-time traffic mapped
on the E-DCH transport channel with 2 ms TTI.
Inter-symbol interference arising from the user's own signal because of multipath propagation can be alleviated with feature RAN1702: Frequency Domain
Equalizer. Features RAN1702: Frequency Domain Equalizer and RAN1308: HSUPA Interference Cancellation Receiver can operate in the same cell at the
localhost:5423/informationbrowser/index.jsp?topic=%2Fm214044344_html%2Fhtm%2Fdocs%2Fru30_feature_descriptions_and_intructions%2Ffd_ran1702_freq_domain_equalizer-0900d80580a1d1f… 3/12
2/28/2021 RAN1308: HSUPA Interference Cancellation Receiver
same time.
Impact on interfaces
This feature impacts interfaces as follows:
Iu: No impacts on protocols. Higher UL data rates possible as a result of improved air-interface.
Iur: No impacts on protocols. Higher UL data rates possible as a result of improved air-interface by HSUPA over Iur.
Uu: No impacts on protocols. Higher UL data rates possible.
Iupc: No impacts
Iub: Control of this feature in the RNC requires changes in the NBAP private messages. Higher UL data rates possible.
O&M: Monitoring and licensing of this feature is needed.
localhost:5423/informationbrowser/index.jsp?topic=%2Fm214044344_html%2Fhtm%2Fdocs%2Fru30_feature_descriptions_and_intructions%2Ffd_ran1702_freq_domain_equalizer-0900d80580a1d1f… 4/12
2/28/2021 RAN1308: HSUPA Interference Cancellation Receiver
Impact on system performance and capacity
This feature impacts system performance and capacity as follows:
large peak data rates for E-DCH users
improved coverage in the UL, for example, for AMR calls existing in parallel with peak rate users
increased cell throughput
increased cell capacity
balanced DL/UL cell capacity
RAS IPA-RNC mcRNC Flexi Multiradio Flexi Multiradio Flexi Lite BTS
BTS 10 BTS
RU30 EP2 RN6.0 2.0 mcRNC2.0 WN7.0 2.0 FSMr3 WN7.0 2.0 WL7.0 2.0
Support not OSS5.4 CD Set 1 Support not Support not Support not Support not
required required required required required
OSS5.4 CD Set 2
1)
1) For RU30 EP2, OSS5.4 CD Set 2 enhances the support with updated parameter descriptions and error corrections. It is strongly recommended to take
the latest NetAct CD set available at the time of deployment.
For Flexi Multiradio BTS WCDMA this feature requires one of the following features:
RAN2382: Flexi BTS Multimode System Module - FSMC
RAN1016: Flexi BTS Multimode System Module (FSMD)
RAN1848: Flexi BTS Multimode System Module - FSME
For Flexi Multiradio 10 BTS WCDMA this feature requires the RAN2262: Flexi Multiradio System Modules (FSMF) feature.
For Flexi Lite BTS WCDMA this feature requires the RAN2157: Flexi Lite BTS 2100 feature.
Note: The RAN1308: HSUPA Interference Cancellation Receiver feature with the RAN1269: 4-Way RX Diversity and the RAN2250: Enhanced HSUPA IC features are supported only with Flexi Multiradio
System Module - FSMF or newer system modules. For more information see RAN3046: Interference Cancellation for 4Rx feature documentation.
Refer to Dimensioning WCDMA RAN: Flexi BTS Baseband for the baseband resource consumption.
Alarms
localhost:5423/informationbrowser/index.jsp?topic=%2Fm214044344_html%2Fhtm%2Fdocs%2Fru30_feature_descriptions_and_intructions%2Ffd_ran1702_freq_domain_equalizer-0900d80580a1d1f… 5/12
2/28/2021 RAN1308: HSUPA Interference Cancellation Receiver
localhost:5423/informationbrowser/index.jsp?topic=%2Fm214044344_html%2Fhtm%2Fdocs%2Fru30_feature_descriptions_and_intructions%2Ffd_ran1702_freq_domain_equalizer-0900d80580a1d1f… 6/12
2/28/2021 RAN1308: HSUPA Interference Cancellation Receiver
localhost:5423/informationbrowser/index.jsp?topic=%2Fm214044344_html%2Fhtm%2Fdocs%2Fru30_feature_descriptions_and_intructions%2Ffd_ran1702_freq_domain_equalizer-0900d80580a1d1f… 7/12
2/28/2021 RAN1308: HSUPA Interference Cancellation Receiver
M5005C40 PIC INDICATION FOR ACTIVE STATE 5005 - HSPA in WBTS Extension
M5005C41 PIC INDICATION FOR INACTIVE STATE 5005 - HSPA in WBTS Extension
Parameters
localhost:5423/informationbrowser/index.jsp?topic=%2Fm214044344_html%2Fhtm%2Fdocs%2Fru30_feature_descriptions_and_intructions%2Ffd_ran1702_freq_domain_equalizer-0900d80580a1d1f… 8/12
2/28/2021 RAN1308: HSUPA Interference Cancellation Receiver
Max target received wide band original power for BTS PrxMaxOrigTargetBTS WCEL
Sales information
localhost:5423/informationbrowser/index.jsp?topic=%2Fm214044344_html%2Fhtm%2Fdocs%2Fru30_feature_descriptions_and_intructions%2Ffd_ran1702_freq_domain_equalizer-0900d80580a1d1f… 9/12
2/28/2021 RAN1308: HSUPA Interference Cancellation Receiver
Sub-steps
a) Select Edit parameters from the WCEL object.
8 Go through the Wizard steps up to the WCDMA Carrier Candidates and Local Cell Group Settings page by clicking the Next button at the bottom of the page.
9 Set a PIC pool to a desired value to enable the RAN1308: HSUPA Interference Cancellation Receiver feature at the BTS.
1 Start the measurement (schedule: 7 days, 00:00-24:00, 15 minute interval) using the RNW Measurement Management application in the Application Launcher.
2 Wait for the next full 15 minutes till the measurement interval starts.
localhost:5423/informationbrowser/index.jsp?topic=%2Fm214044344_html%2Fhtm%2Fdocs%2Fru30_feature_descriptions_and_intructions%2Ffd_ran1702_freq_domain_equalizer-0900d80580a1d1… 10/12
2/28/2021 RAN1308: HSUPA Interference Cancellation Receiver
4 Wait for the next full 15 minutes for the measurement collection and additional 10 minutes for the measurement data to be transferred to the OMS.
5 Compare cell throughput before and after feature activation use the following counters:
Deactivating RAN1308: HSUPA Interference Cancellation Receiver using OMS Element Manager
Procedure
Sub-steps
a) Select Edit parameters from the WCEL object.
localhost:5423/informationbrowser/index.jsp?topic=%2Fm214044344_html%2Fhtm%2Fdocs%2Fru30_feature_descriptions_and_intructions%2Ffd_ran1702_freq_domain_equalizer-0900d80580a1d1… 11/12
2/28/2021 RAN1308: HSUPA Interference Cancellation Receiver
Deactivating RAN1308: HSUPA Interference Cancellation Receiver using BTS Site Manager
Procedure
3 Go through the Wizard steps up to the WCDMA Carrier Candidates and Local Cell Group Settings page by clicking the Next button at the bottom of the page.
4 Set a PIC pool value to none to disable the RAN1308: HSUPA Interference Cancellation Receiver feature at the BTS.
localhost:5423/informationbrowser/index.jsp?topic=%2Fm214044344_html%2Fhtm%2Fdocs%2Fru30_feature_descriptions_and_intructions%2Ffd_ran1702_freq_domain_equalizer-0900d80580a1d1… 12/12