Professional Documents
Culture Documents
Loctite Catalogue
Loctite Catalogue
Loctite Catalogue
LOCTITE® 680™
(TDS for the new formulation of LOCTITE® 680™) August-2016
0
30min 1h 3h 6h 24h 72h 168h
TYPICAL PROPERTIES OF UNCURED MATERIAL Cure Time
Specific Gravity @ 25 °C 1.1
Viscosity, Brookfield - RVT, 25 °C, mPa·s (cP): Cure Speed vs. Temperature
Spindle 3, speed 20 rpm 750 to 1,750LMS The rate of cure will depend on the temperature. The graph
Viscosity, Cone & Plate, 25 °C, mPa·s (cP): below shows the shear strength developed with time at
Shear rate 129 s-1 650 to 1,850 different temperatures on steel pins and collars and tested
according to ISO 10123.
Flash Point - See SDS
TDS LOCTITE® 680™, August-2016
(lb.in.) (190)
Activator SF 7091™ M10 stainless steel nuts and bolts N·m 21
75 (lb.in.) (185)
7471™
Activator SF
50
TYPICAL ENVIRONMENTAL RESISTANCE
Cured for 1 week @ 22 °C
25 Activator SF 7649™ Compressive Shear Strength, ISO 10123:
Steel pins and collars
0
30min 1h 3h 6h 24h 72h 168h Hot Strength
Cure Time Tested at temperature
125
TYPICAL PROPERTIES OF CURED MATERIAL
% Strength @ 22 °C
50
TYPICAL PERFORMANCE OF CURED MATERIAL
Adhesive Properties
25
Cured for 1 hour @ 93 °C, tested @ 22 °C
Compressive Shear Strength, ISO 10123: 0
Steel pins and collars N/mm² ≥24.1LMS -25 0 25 50 75 100 125 150 175 200
(psi) (≥3,500) Temperature, °C
Note:
The information provided in this Technical Data Sheet (TDS) including the
recommendations for use and application of the product are based on our
knowledge and experience of the product as at the date of this TDS. The product
can have a variety of different applications as well as differing application and
working conditions in your environment that are beyond our control. Henkel is,
therefore, not liable for the suitability of our product for the production processes
and conditions in respect of which you use them, as well as the intended
applications and results. We strongly recommend that you carry out your own
prior trials to confirm such suitability of our product.
Any liability in respect of the information in the Technical Data Sheet or any other
written or oral recommendation(s) regarding the concerned product is excluded,
except if otherwise explicitly agreed and except in relation to death or personal
injury caused by our negligence and any liability under any applicable mandatory
product liability law.