Professional Documents
Culture Documents
Vaccum Ri Procedure
Vaccum Ri Procedure
Table of Contents
Page No.
1.0 Purpose
The purpose of vacuum test is to detect any air leakage through the weld seam
to ensure tightness.
2.0 Scope
Applicable to fillet welds and butt welds for watertight structure in lieu of a leak
test.
3.0 Reference
3.1 ABS Rule Hull construction and equipments part 3, chapter 7, section 1
5.0 Procedure
5.2 Visual inspection and NDT requirements have been carried out and
accepted.
5.5 Apply soap water solution in advance on the surface of the weld and
conduct visual inspection.
5.6 If any leakage is detected, the defect weld shall be repaired and re
confirmed by the same test method.
FSO SEPAT
VACCUM TEST PROCEDURE
QUALITY ASSURANCE DEPARTMENT
DOC. NO: 21006-KSL-09000-QA-PR-0008 Rev 00, Need to change to Sepat reference
Page 4 of 4
ON / OFF Valve
Vaccum
Gauge
Air Suction
Rubber
Padding
7.0 Documentation
7.1 Prepare the test report and submit to owner Rep and Class surveyor for
acceptance.