Professional Documents
Culture Documents
Api650 Questionn°03 Open Book Response
Api650 Questionn°03 Open Book Response
Api650 Questionn°03 Open Book Response
Q1. AST fabricated to API 650 (Basic Standard) is normally designed not to
exceed an operating temperature of:
1. 260 deg C
2. 100 deg C
3. 90 deg C section 1-1-1
4. 21 deg C
Q2. Minimum size of fillet welds in the construction or repairs of an AST built to
API Standard 650 is:
Q3. As per API Standard 650, the overlap at lap-welded joints shall be at least
five times the nominal thickness of the thinner plate, but need not exceed,
a. 2” for single-welded lap joints and 4” for double welded lap joints
b. 1” for single-welded lap joints and 2” for double welded lap joints section 5.1-3-5
c. 1.5” for single-welded lap joints and 2” for double welded lap joints
d. 1.5” for single-welded lap joints and 1” for double welded lap joints
Q4. Calculate by the 1-Foot method the design shell thickness Td in inches, of
the following description of tank built to API Standard 650:
Shell Material ASTM A36M
H = Design liquid level = 50 feet
D = Nominal Tank Diameter = 180 feet
G = Design Specific Gravity = 0.86
CA = Corrosion Allowance = 0. 0625”
Sd = Allowable stress in design condition, in psi (23200psi)
td = design shell thickness, inches
St = Allowable stress for hydrostatic test condition, in psi
tt = hydrostatic test shell thickness, inch(es).
a. 0.912”
b. 0.850” section 5-6-3-2
c. 1”
d. 0.922
Q5. Calculate by the 1-Foot method the hydrostatic test shell thickness Tt in
inches, of the above referred tank, when water is used for the test :
a. 0.935”
b. 0.985”
c. 1”
d. 0.922” section 5-6-3-2
Q6. Maximum Reinforcement thickness of vertical butt joints of a tank shell plate
of 28mm, of an AST built to API Standard 650 shall be:
Q7. Vertical joints of a 28mm thick shell of an AST built to API Std. 650 shall be
radiographed to the extent as given below:
a. Full section 81-2-2 c)
b. Partial
c. Spot
d. Nil
Q8. In an AST built to API Standard 650, the bottom annular plates have
radial weld joints, and are single butt welded with permanent back-up bar, in
which case, the extent of radiographing radial joints shall be,
Q9. As per API Std. 650, personnel who perform and evaluate radiographic
examinations (RT) shall have a minimum qualification as follows:
a. Not required
b. Required figure 4.1b table 4.4b
c. Depends on opinion of design engineer
d. Depends on opinion of tank inspector
Q12. Which of the following sets of the Transverse Charpy V-notch Impact
Test Values of a fully killed 0.75 “ thick plate of ASTM A 516 gr 60 for a design
metal temperature of -34 degree C, is acceptable as per API 650? Plates are
not normalized.