Professional Documents
Culture Documents
Msds 33
Msds 33
Ingestion Clean mouth with water. Drink 1-2 glasses of water, do not induce vomiting,
seek medical advice.
Eye Contact Immediately flush eyes with copious amounts of running water (for 10 minutes),
if necessary see an oculist.
Skin Contact Rinse with running water. Replace contaminated clothes.
Inhalation stop/avoid inhalation here n after. If spray mist is inhalated, seek
medical attention
SUITABLE
EXTINGUISHING MEDIA
Extinguish preferably with dry chemical, carbon dioxide (CO2), or foam.
water spray / mist may be used.
Drathon 33 Page 1 of 5
EXTINGUISHING MEDIA WHICH MUST NOT BE USED FOR SAFETY REASON
High pressure water jet, unless used by authorized people.
SPECIAL EXPOSURE HAZARD ARISING FROM THE PRODUCT ITSELF,
FROM COMBUSTION PRODUCTS OR FROM RESULTING GASES
Does not burn (aqueous solution). In case of fire, after evaporation of water
and further heating,
toxic fumes can be release.
SPECIAL PROTECTIVE EQUIPMENT FOR FIREFIGHTERS
Put on breathing apparatus.
PERSONAL PRECAUTION
Avoid contact with skin and eyes.
ENVIRONMENTAL PRECAUTIONS
Do not allow to enter drainage system, surface or ground
water.
METHODS FOR CLEANING UP
Remove with liquid-absorbing material (sand,sawdust). Wash
away residue with plenty of water.
HANDLING
Ensure the work area well ventilated. Use rubber gloves, goggles and protective face.
Use masks in case of atomization / spray of fine.
Do not mix the concentrated product with other substances and preparations. When
diluting,
always stir the product into standing water.
STORAGE
Keep container tightly sealed. Do not store together with strong acids.
CONDITIONS TO AVOID
No decomposition if used according to spesifications
MATERIALS TO AVOID
Reacts with acid : heat released
Reacts with metals (e.g. Al; Zn) : Heat generate and hydrogen release.
HAZARDOUS DECOMPOSITION PRODUCTS
None if used for intended purpose.
INGESTION
Acute oral toxicity : LD50 > 5000 mg/kg body weight (rabbit)
Swallowing will lead to a strong caustic effect on mouth and throat and to the danger
of perforation of esophagus and stomach.
SKIN CONTACT
The product causes corrosion on skin and mucous membranes
EYE CONTACT
Strong corrosive effect.
The following ecological assesment result from the basis of the raw materials contained in the product
and/or of structurally comparable susbstances.
Drathon 33 Page 3 of 5
In case of discharge of acidic or alkaline products into sewerage system the pH must be in the range of
6-10 since higher or lower pH values may damage the sewerage system or impair biological sewage
treatment plants. Local discharge statutes have to be observed.
Drathon 33 Page 4 of 5
SECTION XVI – OTHER INFORMATION
NFPA Rating
Health H=3
Fire F=0
Reactivity R=1
Key :
Blue = health; red = fire; yellow = reactivity; white = spesial hazard
0= minimal; 1=slight; 2=moderate; 3=serious;
4=severe
We believe the statements, technical infomation and recommendations contained herein are
reliable , but they are given without warranty or guarantee of any kind, express or implied, and
we assume no responsibility for any loss, damage, or expense, direct or consequential, arising
out of their use
Drathon 33 Page 5 of 5