Professional Documents
Culture Documents
Ayna Mahruti Bosluk Ve Temas Ayarlari
Ayna Mahruti Bosluk Ve Temas Ayarlari
1
Periyodik Bakým
Ayna Mahruti diþlinin azami sürede kullanýmýný garanti etmek için önemli ve gerekli olan uygun ve doðru bakýmýn saðlanmasýdýr. Bakýmýn en
önemli ihtiyacý yaðlamadýr, bu nedenle yetersiz ve doðru olmayan yaðlama diþlilerde ciddi hasarlara sebep olabilir. Uygun yað kullanýlmasý,
yaðýn düzenli zaman aralýklarýnda deðiþtirilmesi ve difransiyel içinde sabit bir seviyede bulundurulmasý tavsiye edilir. ( HYPOID YAÐI KULLANIN)
Revizyon ve Ayarlama
Kusurlu veya bozulmuþ bütün parçalarýn deðiþim ve yeniden doðru olarak takýlmasý, revizyon yapýlan diþlinin azami sürede kullanýmýný saðlamak
bakýmýndan son derece önemlidir. Parçalarýn dikkatli bir þekilde gözle incelenmesi ve temizliði esastýr. Revizyondan istenilen en iyi neticeyi
elde etmek için, düþük maliyetli conta, burç ve mesafe pullarý gibi bütün parçalarýn deðiþtirilmesi tavsiye edilir, tabii ki tüm aþýnmýþ veya zarar
görmüþ parçalarýnda. Rulmanlarýn öngerilim ayarlama yöntemi daima uygulanmalýdýr. Rulmanlarýn öngerilim ayarlama yöntemi diþlinin marka
ve modeline göre deðiþiklik arzettiðinden orjinal imalatçý firmanýn servis el kitabýna müracaat edilmesi tavsiye edilir. 2
Recommended Backlash
Backlash is the space between the teeth of the crown and pinion and it must be measured perpendicular to the teeth surface. This parameter Q
is very important. Too low backlash may cause teeth seizure, too high space may cause noise and eventually teeth breaking. To measure the
backlash, position the comperator at the a teeth of the crown, close to the base of the teeth perpendicularly, like in figure 3. Move the crown
slowly back and forth, keeping the pinion from moving. The needle of the comperator will show you the value of the backlash. Adjust the backlash
using bearing adjusters and shims until the value recommanded by the manual of your axle service is achieved. If you dont have the service
manual, using the practical method below may give you the recommended backlash value.
1. Measure the outer diameter of the crown gear (Q in Figure 2) 3
2. Count the teeth number of the crown wheel Z
3. The ratio between the outer diameter 'Q' (in milimeters) and number of teeth 'Z' gives the approximate value of module M: M=Q/Z
If the diameter Q is measured in inches, multiply the value by 25.4 to convert it to milimetres.
4. Find the recommended marked backlash (4) from the table below.