Professional Documents
Culture Documents
Instructions: Hottest Spot Thermal Indicator
Instructions: Hottest Spot Thermal Indicator
I.L. 46-717-ll
INSTRUCTIONS
.c
BI-METAL TYPE
HOTTEST SPOT THERMAL INDICATOR
For Sealed Dry-Type Transformers
ls
ua
THE HOTTEST SPOT THERMAL INDI transformer, carries a current proportional to load,
CATOR is an auxiliary piece of apparatus used to and has a thermal time constant approximately
indicate the hottest spot in the transformer winding. equal to that of the transformer. The thermometer
This temperature is approximately duplicated on bimetal located inside the heating coil will there
the bimetal of the dial type thermometer and is
an
fore attain a temperature approximately that of the
read directly on the indicator dial. transformer winding.
tM
The weatherproof dial type indicator is mounted
on the tank wall of the transformer. The dial is
calibrated from 0 to 250 degrees centigrade and INSTALLATION AND MAINTENANCE
has a resetable maximum temperature hand. The thermal indicator and current transformer
Three signal or alarm contacts are available that is completely mounted and adjusted at the factory
ar
are rated at a maximum current given in Table No. before shipment and should not require any service
1. The contacts close at 200°, 210° and 220° centi at the time of installation. If it becomes necessary
grade. The contacts open at 5° less than the closing to repair the instrument contact the nearest West
lP
temperature. The alarm leads are brought out of inghouse Sales Office.
the instrument through a triple seal connector with
a locating pin to prevent incorrect connections. Table No. 1
The current transformer is mounted outside the
ca
case of the main transformer and is energized from CONTACT LOAD LIMIT
I I
Volts Amperes Volts Amperes
a current proportional to the load of the main trans ------ -----------
former.
125
I 10 125 I
lec
Y2
250 5 250 !14
OPERATION 460 3 ... I
I
I I
!
The heating coil, located in the hot gas of the
RED
}
.E
{ }
BLACK
COIL
GREEN
VIEW LOOKING AT
ww
BOTTOM OF CAS E