Professional Documents
Culture Documents
ECDIS V3.xx Upgrade Guide
ECDIS V3.xx Upgrade Guide
xx upgrade guide
GWD12098 | 2017-09-29
Introduction
This guide describes how to upgrade current Danelec Marine DM800 ECDIS G2 and DM700 ECDIS
systems running software version 3.xx to a new version.
Danelec Marine ECDIS has a unique software architecture enabling the user of the ECDIS to install
upgrades to the system in a simple and safe manner, without the assistance of service technician.
Tools needed
- A USB drive
- DM800 V3.xx upgrade file (.mbp file extension)
Important note
- Never attempt to upgrade the system while navigating at sea or at any time where the ECDIS
is required for navigation or safety related operations. Wait until vessel is in a safe position.
- During the upgrade procedure the ECDIS cannot be used for navigation.
- If there is more than one ECDIS system in the installation (cluster), the software upgrade must
be performed on all ECDIS stations.
- While performing the ECDIS upgrade on one ECDIS DPU all others DPUs in the ECDIS
cluster must be in standby mode to avoid any issues related to synchronization between
different software versions.
Page 1 of 4
ECDIS V3.xx upgrade guide
GWD12098 | 2017-09-29
Step-by-step guidance
Preparation:
Upgrade:
Enter the Master password to open the menu. (Master password is set to “0000” by
default, unless it has been changed by the master of the vessel)
Page 2 of 4
ECDIS V3.xx upgrade guide
GWD12098 | 2017-09-29
6. Click “Yes”
Page 3 of 4
ECDIS V3.xx upgrade guide
GWD12098 | 2017-09-29
Should you have any questions in relation to the ECDIS upgrade procedure, please do not hesitate to
contact us at support@danelec-marine.com for technical issues or at sales@danelec-marine.com
for any other matters.
Page 4 of 4