Teile Und Zubehör - Einbauanleitung: Park Distance Control (PDC)

You might also like

Download as pdf or txt
Download as pdf or txt
You are on page 1of 17

Teile und Zubehör - Einbauanleitung

F 36 66 069

Park Distance Control (PDC)


BMW 3er-Reihe, Limousine, Coupé, Cabrio, touring, compact
(E 36/4, -/2, -/C, -/3, -/5)
Nur zum Gebrauch in der BMW HO bestimmt.
Einbauzeit ca. 3 Stunden, die je nach Zustand und Ausstattung des Fahrzeuges abweichen kann.
Elektrokenntnisse sind Voraussetzung.

BMW Parts and Accessories – Installation Instruction


Park Distance Control (PDC)
BMW 3 Series, saloon, Coupé, Convertible, touring, compact (E 36/4, -/2, -/C, -/3, -/5)
Instructions de montage des pièces et des accessoires BMW
Contrôle de distance au stationnement (PDC)
BMW Série 3, berline, coupé, cabriolet, touring, compact (E 36/4, -/2, -/C, -/3, -/5)
BMW Onderdelen en accessoires – Montagehandleiding
Park Distance Control (PDC)
BMW 3-serie, sedan, coupé, cabrio, touring, compact (E 36/4, -/2, -/C, -/3, -/5)
BMW Delar och tillbehör – Monteringsanvisning
Park Distance Control (PDC)
BMW 3-serie sedan, coupé, cabriolet, touring, compact (E 36/4, -/2, -/C, -/3, -/5)
Ricambi e accessori BMW – Istruzioni di montaggio
Park Distance Control (PDC)
BMW Serie 3, berlina, Coupé, Cabrio, touring, compact (E 36/4, -/2, -/C, -/3, -/5)
BMW piezas y accesorios – instrucciones de montaje
Sistema de Control de Distancia Posterior (PDC)
BMW Serie 3 berlina, Coupé, Cabrio, touring, compact (E 36/4, -/2, -/C, -/3, -/5)
Peças e Acessórios BMW – Instruções de Montagem
Park Distance Control (PDC)
Modelos BMW da Série 3, Berlina, Coupé, Cabriolet, touring e compact (E 36/4, -/2, -/C, -/3, -/5)

Best.-Nr. 01 29 9 415 408 V/98 Printed in Germany 1


Park Distance Control (PDC)
BMW 3 Series, saloon, Coupé, Convertible, touring, compact (E 36/4, -/2, -/3, -/5)

Only for use within the BMW dealer organisation. 1/2 inch extension
Fitting time approx. 3 hours, depending on the 1/2 inch SW 10 mm, 13 mm, 16 mm
condition of and equipment in the car. and 17 mm sockets
Electrical skills are required. Torx wrench
Drill
3.5 mm and 9 mm twist drill bits
General notes 40 mm stage drill bit
The fitting method is shown for left-hand drive Special tool to remove jacks
models. For right-hand drive models the fitting Special crimping tool
work must be carried out the opposite way round Water-soluble pen
on some occasions. Hammer
Round file
If the PIN slots specified in these instructions are Tape measure
already assigned, bridges, double crimps or Zinc-rich primer
parallel connections must be used.

Up to model year 1994, smooth painted bumper Table of contents


guards were fitted in the vehicles. The use of
bumper guards for PDC (textured surface) in the Section
rear bumper means that fitting replacement front 1. Preparatory work on the car
bumper guards may also have to be considered to 2. Power supply wiring harness/Overview
keep the car's uniform appearance. 3. Ultrasonic transducer wiring harness/Overview
4. To fit the power supply and ultrasonic
Cable installation transducer wiring harnesses
Keep precisely to the designated cabling routes in 4.1 Model E 36/2, -/4
the vehicle to avoid faults. 4.2 Model E 36/3
4.3 Model E 36/5
Under no circumstances should you use 4.4 Model E 36/C
"Scotchlock quick connectors" since they may 5. To fit the bracket, ultrasonic transducer and
cause faults in the vehicle electrical systems. bumper guards
6. Circuit diagram
Ensure that when you fit the cables in the car they
are not kinked or damages since otherwise faults
may occur whose later location may require a great
deal of work. The costs incurred by this work will 1. Preparatory work on the car
not be reimbursed by BMW.
- Print out the error memory
Tools and equipment required - Disconnect the battery
Cross slot screwdriver - Remove the rear bumper
Straight slot screwdriver
SW 10 mm open-ended spanner
Centrepunch 2. Power supply wiring harness/
Anti-corrosion paint Overview
1/2 inch reversible ratchet
F 36 66 070

Code designation/
Item Description Cable colour Connection point in car
Pug-in-place
A 1-pole pin casing Blue/Yellow Connect to connector A1
A1 1-pole socket casing To jack from tail light unit and connect to
connector A
B Jack Blue/Yellow In the plug for left or right (E 36/5) tail light X 318/E36/5
unit X 319/E36
C 1-pole pin casing Brown Connect to connector C1

C1 1-pole socket casing To jack from tail light unit and connect to
connector CA
D Jack Brown In the plug for left or right (E 36/5) tail light X 318/E36/5
unit X 319/E36
E 2-pole plug To PDC gong X 363

F 26-pole plug To PDC control unit X 300

17
3. Ultrasonic transducer wiring harness/Overview
F 36 66 071
Cable colour/ Connection point in car Code designation/
Item Description Cross-section Pug-in-place
G 26-pole plug To control unit in left or right (E 36/5) X 18013
rear side section
H Socket To ultrasonic transducer, left X 18020

I Socket To ultrasonic transducer, centre left X 18021

J Socket To ultrasonic transducer, centre right X 18022

K Socket To ultrasonic transducer, right X 18023

4. To fit the power supply and Fit the plug (F) to the left-hand wheel arch and
plug (E) to the rear window shelf.
ultrasonic transducer wiring
harnesses F 36 66 077

4.1 Model E 36/2, -/4 Centrepunch the dimensions and drill the holes
with a 5.5 mm twist bit. Expand the hole to a
F 36 66 072 diameter of 32 mm.

Fit the power supply wiring harness (1) from the tail A = 135 mm, B = 30 mm
light unit (2) to the control unit (3) and to the rear
window shelf (4). Fit the ultrasonic transducer F 36 66 078
wiring harness (5) from the control unit (3) to the
ultrasonic transducers (6). Drill the holes (1) with a diameter of 5.5 mm and
thread the cable straps (2) through them. Secure
F 36 66 073 the wiring harness (3) in the cable straps (2).
Thread the plug (G) through the hole and move it to
Remove the luggage compartment mat (1), side the installation site for the control unit. Insert the
trim (2) and the tail light covers (3) on both sides. grommet (4).

F 36 66 074 F 36 66 079

Remove the nuts (1) and expanding rivets (2). Fit the plug (E) for the power supply wiring
Take the floor cover (3) out of the car. harness (1) from the luggage compartment through
the grommet (2) to the rear window shelf.
F 36 66 075
F 36 66 080
Remove the expanding rivets (1). Fold back the
rear trim (2) in the direction indicated by the arrow. Connect the plug (E) to the PDC gong (1).
Pull the wiring harness (3) out of the clips. Remove
the rear trim (2). F 36 66 081

F 36 66 076 Insert the thread and journal of the PDC gong into
the holes and secure it under the rear window shelf
Disconnect the jacks (1, 2) from the socket (3) in using a hexagonal nut (1).
the left-hand tail light unit.
Vehicles with a low recess in the rear window
E 36/2 Jack (1) Pin 5 shelf
Jack (2) Pin 1
E 36/4 Jack (1) Pin 6 F 36 66 082
Jack (2) Pin 4
Secure the bracket (1) on the PDC gong (2) using
Connect jack (1) into socket casing (A1) and the nut (3) and bolt the assembly to the vehicle
jack (2) into socket casing (C1). beneath the rear window shelf using the nut (4).
Connect connector (A) to connector (A1) and
connector (C) to connector (C1). All models E 36/2, -/4
Connect up connectors (B and D) in socket (3) as
follows: F 36 66 083

E 36/2 Connector (B) Pin 5 Secure the bracket (1) using hexagonal screws (2).
Connector (D) Pin 1 Insert the plugs (F, G) into the counter plugs of the
E 36/4 Connector (B) Pin 6 same colour on the control unit and secure them
Connector (D) Pin 4 with the fuse bars (3).

18
4.2 Model E 36/3 F 36 66 091

F 36 66 084 Move the plug (G) for the ultrasonic wiring


harness (1) to the installation site for the
Fit the power supply wiring harness (1) from the tail control unit.
light unit (2) to the control unit (3) and to the left-
hand ventilation grille (4). Fit the ultrasonic F 36 66 092
transducer wiring harness (5) from the control
unit (3) to the ultrasonic transducers (6). Place the speed nuts (2) on the trim (1) and secure
the control unit (3) using cross slot screws (4).
F 36 66 085 Fit the trim (1).

Open the cover (1), remove the tail light covers (2) F 36 66 093
on both sides. Undo the cross slot screws (3) and
remove the D column trim (4). Remove the rear Insert the plugs (F, G) into the counter plugs of the
trim (5). same colour on the control unit (1) and secure
them with the fuse bars (2).
F 36 66 086
F 36 66 094
Remove the cross slot screw (1) and the C pillar
trim (2). Take out the cover (3). Pull the insulation mat (1) out of the grille (2) and
mark the dimensions. Drill holes using a 6.5 mm
F 36 66 087 twist drill bit.

Remove the cross slot screws (1) and ventilation A = 36 mm, B = 10 mm


grille (2). Undo the cross slot screws (3) and
remove the bracket (4). F 36 66 095

F 36 66 088 Cut the nipple (2) off the PDC gong (1). Secure the
PDC gong (1) using the hexagonal nut (3).
Lever out the cover (1), undo the cross slot
screws (2) and remove the belt mounting (3). F 36 66 096
Undo the expanding rivet (4) and remove the
cover (5). Cut out the insulation mat (1) and connect the
plug (E) to the PDC gong (2).
F 36 66 089

Undo the hexagonal nut (1) and the cross slot 4.3 Model E 36/5
screws (2) and remove the trim (3).
F 36 66 097
F 36 66 090
Fit the power supply wiring harness (1) from the tail
Disconnect jacks 1 (pin 6) and 2 (pin 4) from the light unit (2) to the control unit (3). Fit the ultrasonic
socket (3) on the left-hand tail light unit. Connect transducer wiring harness (4) from the control unit (3)
jack (1) to socket casing (A1) and jack (2) to socket to the ultrasonic transducers (5).
casing (C1). Connect connector (A) to connector
(A1) and connector (C) to connector (C1). Connect F 36 66 098
connectors (B and D) to the socket (3) as follows:
Remove the tail light units on both sides. Take out
Connector (B) Pin 6 the luggage compartment mat (1). Remove the
Connector (D) Pin 4 plastic nut (2) and lever out the left-hand luggage
compartment tray (3).
F 36 66 077
F 36 66 099
Centrepunch the dimensions and drill the holes
with a 5.5 mm twist bit. Expand the hole to a Remove the plastic nuts (1) and lever out the right-
diameter of 32 mm. hand luggage compartment tray (2).

A = 135 mm, B = 30 mm F 36 66 100

F 36 66 078 Remove the rivets (1) and take out the rear trim (2).

Drill the holes (1) with a diameter of 5.5 mm and


thread the cable straps (2) through them. Secure
the wiring harness (3) in the cable straps (2).
Thread the plug (G) through the hole and insert
the grommet (4).

19
F 36 66 101 F 36 66 108

Disconnect jacks 1 (pin 6) and 2 (pin 8) from the Open the hood box cover (1) slightly (30 mm to
socket (3) on the right-hand tail light unit. Connect 50 mm). Then push the hood box cover
jack (1) to socket casing (A1) and jack (2) to socket downwards in the direction indicated by the arrow
casing (C1). Connect connector (A) to connector (A1) so that the luggage compartment lid (3) can be
and connector (C) to connector (C1). Connect opened.
connectors (B and D) to the socket (3) as follows:
F 36 66 109
Connector (B) Pin 6
Connector (D) Pin 8 Remove the luggage compartment mat. Take out
the tail light units on both sides. Undo the
Fit the plugs (E and F) to the bracket for the control expanding rivet (1) and remove the left-hand
unit. luggage compartment trim (2). Unscrew the plastic
nuts (3) and take out the cover (4).
F 36 66 102
F 36 66 110
Centrepunch the dimensions and drill the holes
with a 5.5 mm twist bit. Expand the hole to a Unscrew the expanding rivet (2) and plastic nut (1)
diameter of 32 mm. and then remove the cover (3).

A = 110 mm, B = 55 mm F 36 66 075

F 36 66 103 Remove the expanding rivets (1). Fold back the


rear trim (2) in the direction indicated by the arrow.
Drill the holes (1) with a diameter of 5.5 mm and Pull the wiring harness (3) out of the clips and then
thread the cable straps (2) through them. Secure remove the rear trim (2).
the wiring harness (3) in the cable straps. Insert the
grommet (4). Fit the plug (G) to the installation site Vehicles with electric hood only
for the control unit.
F 36 66 111
A = 400 mm, B = 700 mm, C = 970 mm

F 36 66 104 Do not move the mechanism for the hood flap


and electric motor.
Secure the control unit (1) with plastic nuts (3) and
the signal generator (2) with the hexagonal nut (4) Push the bar (1) in the direction indicated by the
to the bracket (5). arrow until the motor (2) is released. Undo the
spring clips (3) and disconnect both Bowden
cables. Remove the securing clips (5). Undo the
The plug connections point upwards. spring clips (6) and taken out the strut (7).

F 36 66 105 F 36 66 112

Fit the nut bracket to the car. Disconnect the plug (1). Unscrew the hexagonal
nuts (2) and remove the bracket (3).
F 36 66 106
All E 36/C models
Insert the plugs (F, G) into the counter plugs of the
same colour on the control unit (1) and secure F 36 66 113
them with the fuse bars (2). Insert the plug (E) to
the signal generator (3). Secure the bracket (4) with Disconnect jacks 1 (pin 5) and 2 (pin 1) from the
hexagonal screws (5). socket (3) on the left-hand tail light unit. Connect
jack (1) to socket casing (A1) and jack (2) to socket
casing (C1).
4.4 Model E 36/C Connect connector (A) to connector (A1) and
connector (C) to connector (C1).
F 36 66 107 Connect connectors (B and D) to the socket (3)
as follows:
Fit the power supply wiring harness (1) from the tail
light unit (2) to the control unit (3) and to the right- Connector (B) Pin 5
hand trim (6). Fit the ultrasonic transducer wiring Connector (D) Pin 1
harness (4) from the control unit (3) to the
ultrasonic transducers (5). Fit the plug (F) to the left-hand wheel arch and
plug (E) through the cable passage in the left-hand
backrest to the right-hand side.

20
F 36 66 114 F 36 66 122

Secure the control unit (1) to the bracket (3) using Hammer the expanding pins (1) downwards and
plastic nuts (2). Only turn the cross slot screws (4) lever the expanding rivets (2) out of the bumper.
on the bracket (3) in a few turns.
F 36 66 123
F 36 66 077
Carefully lift out the bumper support (1) and the
Centrepunch the dimensions and drill the holes bumper insert (2).
with a 5.5 mm twist bit. Expand the hole to a
diameter of 32 mm. E 36/5 models only

A = 135 mm, B = 30 mm F 36 66 124

F 36 66 078 Undo the hexagonal nut (1), then pull out the Torx
bolt (2). Lift out the impact absorber (3).
Drill the holes (1) with a diameter of 5.5 mm and
thread the cable straps (2) through them. Secure Vehicles without standard holes only
the wiring harness (3) in the cable straps (2).
Thread the plug (G) through the hole and insert the F 36 66 125
grommet (4). Fit the plug (G) at the control unit's
installation site. Insert the support for PDC (1) into the bumper
casing (2). Secure it in position with several
F 36 66 115 expanding rivets and then mark the holes for the
sensors. Remove the support and drill the holes.
Insert the plugs (F, G) into the counter plugs of the
same colour on the control unit (1). F 36 66 126

F 36 66 116 Secure the bracket (1) with hexagonal nuts (3) and
Torx bolts (4) to the support for PDC (2). Then
Push the control unit into the gap between the insert the bracket in the rear trim and secure it with
wing and the luggage compartment plate. Push the expanding rivets.
cross slot screws on the bracket (1) through the
oval holes and secure them, F 36 66 127

F 36 66 117 Fit the bumper guards (1). Align and secure the
bumper guard (2).
Fit the plug (E) for the power supply wiring
harness (1) from the luggage compartment to
the seat box and connect it to the standard cable The angled section on the centre bumper
ties (2). Fit the plug (E) to the right-hand side of guard must point upwards.
the car.
F 36 66 128
F 36 66 118
Fit the ultrasonic transducers in the bumper guards
Connect the plug (E) into the PDC gong (1) and from the rear.
secure the PDC gong (1) to the bracket (3) using
the hexagonal nut (2). Ensure that the journal (4)
locks into the hole provided for it. The ultrasonic transducers must lock into the
mountings.
F 36 66 119
F 36 66 129
Secure the bracket (1) to the existing welded studs
using the plastic nuts (2). Connect the plugs to the ultrasonic transducers
and secure the bumper to the car.

5. To fit the bracket, ultrasonic For all cars


transducer and bumper guards
The fusible insert for the reversing lights also
F 36 66 120 acts as the fuse for the Park Distance Control.
After fitting, a note is to be made on the sticker in
Carefully lever out the bumper guards (1) in the fuse box.
the direction indicated by the arrow using a
screwdriver, and remove them.

F 36 66 121

Hammer the expanding pins (1) inwards and lever


the expanding rivets (2) out of the bumper.

21
6. Circuit diagram
Legend

X18013 PLUG FOR SENSOR WIRING HARNESS


A81 PDC CONTROL UNIT
H40 PDC GONG
X300 PDC CONTROL UNIT PLUG
X319 TAIL LIGHT
X363 PDC GONG
X001 REVERSING LIGHT CONNECTOR
X18020 TRANSDUCER PLUG REAR LEFT
X18021 TRANSDUCER PLUG REAR
CENTRE LEFT
X18022 TRANSDUCER PLUG REAR
CENTRE RIGHT
X18023 TRANSDUCER PLUG REAR RIGHT
B34 SENSOR REAR LEFT
B35 SENSOR REAR CENTRE LEFT
B36 SENSOR REAR CENTRE RIGHT
B37 SENSOR REAR RIGHT

22
1

A1
B E
A

C D F

C1
F 36 66 070

G H J

I K
F 36 66 071
2

3 4
2

6
3
4 6
5 6 1
6
1 3 2
F 36 66 072 F 36 66 073

5 6
2 3

1
2
3
1

F 36 66 074 F 36 66 075

7 8
E
F
B 1 A1
A
B

D 2 A
C1 C
3
F 36 66 076 F 36 66 077

9 10

G 1 2 1
E
210 1 500 350 1

4 2
3
F 36 66 078 F 36 66 079
3

11 12

E
1 1
F 36 66 080 F 36 66 081

13 14
3

2
F
3
2 G
1 2 1
4 3 F 36 66 082 F 36 66 083

15 16
4
6
6 3
4 6
2
6
1 352
5 1
F 36 66 084 F 36 66 085

17 2 18
1

1 1
3 3

4 3 2

F 36 66 086 F 36 66 087
4

19 20

2 2 2
2
5
3 3
1
4 1

F 36 66 088 F 36 66 089

21 22
1 A1 A
B E

B
3
D
F A
2 C1 C

F 36 66 090 F 36 66 077

23 24

G 1 1
210 1 500 350 1

G
4 2
3
F 36 66 078 F 36 66 091

25 26
2 2
4 F 2 G 2
3
4
1

1
F 36 66 092
F 36 66 093
5

27 28
1 B
2 1 3

A 2

F 36 66 094
F 36 66 095

29 30
E 3 1 2
5
5
1 4
2 5
5

F 36 66 096 F 36 66 097

31 32

3
2
1

2
1

F 36 66 098 F 36 66 099

33 34 E

F A
A1
2
2
D
C B
1 1 1 C1
1
F 36 66 100
3
F 36 66 101
6

35 36 G
1 C
B
A

B
2 1
1
2
2
A 3 4

F 36 66 102 F 36 66 103

37 2 38

4 5
1

3
1
V
PDC
12 3
F 36 66 104 F 36 66 105

39 40
3 6
2 E 5
G 2 4
5 F 1
4 1
5 5
3 2
F 36 66 107
F 36 66 106

41 42
2
1
1 2 3 1

4
3
F 36 66 108 F 36 66 109
7

43 44
3

1
2 2
3 1

F 36 66 110 F 36 66 075

45 46
6 7

2 6
2
3
4
1
3
3 4 5
1 2
F 36 66 111 2 F 36 66 112

47 48
B 1 A1
A 2 2
E
1
D 2 C1
C
3
4
3
F F 36 66 113 4 F 36 66 114

49 50

G 1
B

210 1 500 350 1

4 2
3
F 36 66 078
F 36 66 077
8

51 52

F 2
G
1
1
2
F 36 66 115 F 36 66 116

53 54
1

E
2
4
E 2 1

2 3
F 36 66 117 F 36 66 118

55 56
1
2
1
1
1

F 36 66 119 F 36 66 120

57 58
1 2
1

F 36 66 121 F 36 66 122
9

59 60
3
2

2
1
1

F 36 66 123 F 36 66 124

61 62
2 4 2

1 3
1
F 36 66 125 F 36 66 126

63 64

2
1

F 36 66 127 F 36 66 128

65 66

F 36 66 129
S 1 KAR 1 KAR S 1 KAR 1 KAR

RS X319S RS X319B 31
X319S 31
X319B

0.75 1.5
BLGE BR

0.5 0.5
BLGE BR

X001
VB RS
RS
KAR

0.5 0.5
BLGE BLGE

X300
26 6 14 KAR

RS RS 31
STG PDC

A81
LS+ LS-
25 21 KAR 13 26 10 23 8 21 12 25 STOSSFAENGER

X300 HL+ HL- HML+ HML- HMR+ HMR- HR+ HR-


X18013

0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5 0.5
BLRT BLGR TR SCHIRM TR SCHIRM TR SCHIRM TR SCHIRM

1382470.9 1382470.9 1382470.9 1382470.9

LTG. 1-ADR. GESCHIRMT LTG. 1-ADR. GESCHIRMT LTG. 1-ADR. GESCHIRMT


LTG. 1-ADR. GESCHIRMT

X363 X18020 X18021 X18022 X18023


2 1 1 2 1 2 1 2 1 2
LAUTSPRECHER PDC

LS+ LS- HL+ HL- HML+ HML- HMR+ HMR- HR+ HR-
WANDLER HMR
WANDLER HML
WANDLER HL

WANDLER HR

H40 B34 B35 B36 B37

FERTIGE LTG NR. 8 357822

You might also like