Professional Documents
Culture Documents
Job Description
Job Description
1.0 Purpose:
The purpose of this SOP is to lay down the procedure for Pest & Rodent Control
treatment in the plant .
2.0 Scope:
This procedure is applicable for controlling the pest and rodent in the
Factory premises,
General corridor,
Service floor, Administration Block,
Canteen
Utility,
Change room, and
The outer periphery of the premises and for the cleaning of the interlocutors.
3.0 Responsibility:
Housekeeping department officer/Executives shall be Responsible for effective
application OF SOP For Pest & Rodent Control.
4.0 ACCOUNTABILITY
5.0 DEFINITION
NA
6.0 Procedure
6.1.1 Pest Control & Rodent Control are carried out by an external recognized
expert agency.
6.1.2 Service contracts with the pest & rodent control agency shall be reviewed on
yearly basis
6.2.1 Glue pads are used only in special cases like noticing a rodent in a particular
area.
6.2.2 Provide the glue pads as and when required.
6.2.3 If any Rodent is caught in the glue trape alive it shall be released outside the
premises.
Nuvan D.D.V.P – 76% E.C To kill a wide range of house fly -Outside area
6.5 Insectocutor
6.5.1 Insectocutors are electrical devices that contain blue colored tube lights and a
wire net with high voltage current.
6.5.2 These are placed at all the entry points so as to trap a flying insect and prevent
it from entering the production area or ancillary areas.
6.5.3 Insectocutors are required to remain ON all 24 hours of the day.
Clean the interlocutors at least once a week by the following procedure:
Switch OFF the electrical supply and open the cover.
6.8.2 Carry out the spray as per schedule with the pesticides of appropriate
6.8.3 Check the area for any cockroach. Remove the dead cockroach if any by
burying in the land.
6.8.4 Document the spraying activity and observation in the annexure AG009-06-
01.
6.8.5 The frequency of Mosquito and Cockroach Control is monthly.
7.0 ATTACHMENTS
8.0 REFERENCE(S)
9.0 ABBREVIATION
Revision History