Professional Documents
Culture Documents
Linear Guide Specification Sheet For New Applications: Speed and Travel: Environment: Load Conditions
Linear Guide Specification Sheet For New Applications: Speed and Travel: Environment: Load Conditions
Linear Guide Specification Sheet For New Applications: Speed and Travel: Environment: Load Conditions
Z-Coordinate
Outside Use Fs2 Fs1
Driving Mechanism
Ramp Time (t1): sec Splash
Corrosive Y-coord:
Y-Coordinate
mm Span
High Humidity (distance)
Duty Cycle: Contaminated Z-coord:
Food/Medical (distance) mm Slider span: mm
Life Expectation:
(years) Fz dy
Z Y Fy
Other Comments: Fr3 Fr1 A dx
dy
Cycles per Hour: Fr4 Fr2 A
dz Fx
Fs3
Operating Hours: Fs4 Fr2 Fr1
Y
(per day) Fs1
Fs2 Fs2 Fs1
Z-Coordinate Span X
Operating Days:
(per year) Driving Mechanism
Fr4 Fr3
COG coords:
Y-Coordinate (distance) Fs4 Fs3
Datum Surface
Junction
Datum Surface
Rail A Rail B
Datum Surface
W2
G1 G2 G1 G2
Length Length
Overall Length
Datum Surface
W3
Phone: 1-800-255-4773 Fax: (317) 728-5050
LINEAR GUIDE EXPLANATION OF TERMS
Series:
NH: Self-aligning for high loads in vertical direction, resistant to impact loads LE/PE: Wide miniature design for single rail applications, stainless steel standard
NS: Self-aligning for medium loads in vertical direction, resistant to impact loads LU/PU: Miniature design with equal load carrying capacity in vertical and lateral
LW: Wide design for single rail applications directions
Accuracy:
For interchangeable part numbers, only PC accuracy is available.
Mounting height H - distance from rail bottom datum face to ball slide top face.
Mounting width - Distance from rail side datum face to ball slide side datum face.
Running parallelism - variation of top of ball slide to bottom of rail or from side of ball slide to side of rail when the ball slide is moving.
Tolerance of NH Series Interchangeable Type: Normal Grade PC Tolerance of NS and LW Series Interchangeable Type: Normal Grade PC
Model No. Model No. NS
NH15, 20, 25, 30, 35 NH45, 55, 65
Characteristics Characteristics LW17, 21, 27, 35, 50
Datum Setup:
D
C D
C
H H
A
Groove mark A
B Groove mark Groove mark
for datum surface for datum surface B for datum surface
(Marked on either W2 KL mark
W3 (Marked on either
KL mark
lateral or bottom Reference rail lateral or bottom
surface for a rail) of preloaded Reference rail
of preloaded surface for a rail)
assembly type only
assembly type only
Mounting width W 2 Mounting width W 3
Matched Set:
A matched set is a set of two or more rail and ball slide setups that are ground to the appropriate height variation tolerances.