Professional Documents
Culture Documents
Ce20100-Introduction To Civiliengineering and Materials - Midterm 2012
Ce20100-Introduction To Civiliengineering and Materials - Midterm 2012
Ce20100-Introduction To Civiliengineering and Materials - Midterm 2012
' i
GENERAL INSTRUCTIONS:
There is no need of an answer-script, Please answer all questions within the booklet
provided. If you require additional space compared to what is provided please write
answers at the back of the page. Please make the answers are brief and to the point.
Marks for each question are provided in parenthesis.
Marks Obtained:
NAME:
.i
Roll No.: \
I \
The question paper consists of 4 pages (including the cover page) arid there are a total .
of 24 questions. Please ensur~ that you nave the correct set, number of pages and /
questions before you
start. ~ I
I
NOTE: If you have doubts with regards tp the question, answer the question the way
you think fit and also write your doubts. Yo.u will be given marks if that doubt makes
sense and that .particular question has wrong
.
wording or insufficient information for
proper answermg.
I•
.,
••'
Q.2. Explain the primary difference between pretensioning and posttensionjng. (1)
Q.3. Explain the differe~ce b~t':Veen shrinkage and creep in concrete structures. (2)
' <
Q.6. During the stage of mix design what is the primary difference between the
constituents of Engineered Cement Composite and conventional concrete. (2)
,.r
2/4
Q.8. Holl)ogeneity in composition after set is a property which is ensured by (1)
a) Conventional Portland cement concrete
/
b) Self Consolidating concrete
c) Puzzolonic ceme~t concrete
d) Foamed concrete .
.. <I •·
Q.13. What is the primary utility of using air-entrained concrete over non air-
entrained conventional concrete. (1)
. .
Q.14. How can ~hrinkage be reduced in concrete (1)
a) low water/cement ratio
b) high water/cement ratio .
c) high aggregate' content
d) low aggregate content
e) both a) and c)
f) both b) and d)
g) none of the above
/
Q.15. Ifthe nominal maximum size ofthe aggregate is increased, then the bulk
· volume fraction of coarse aggregates to concrete volume ( 1)
a) increases
b) decreases
.. <I
- .. .;,
3/4
/
Q.l3. What is the-primary. utility of using air-entrained concrete over non air-
·f_, entrained conventional concrete. · . (1}
{
.. ~ Q.15. Ifthe nominal ~axitl:nim.~ize of the aggregate is in~reased, then the bulk
volume fraction of coarse' aggregates ·to concrete volume · (1)
a) increase~ · . ·. ·
b) decreases
3/4
. '