Installing The 266-8480 Temperature Control Kit (Manual) On 300 Series B Excavators (7304)

You might also like

Download as pdf or txt
Download as pdf or txt
You are on page 1of 12

330B L Excavator 6DR00001-UP (MACHINE) POWERED BY 3306 Engine(SEBP2437...

Page 1 of 25

Shutdown SIS

Previous Screen

Product: EXCAVATOR
Model: 330B L EXCAVATOR 6DR
Configuration: 330B L Excavator 6DR00001-UP (MACHINE) POWERED BY
3306 Engine

Special Instruction
Installing the 266-8480 Temperature Control Kit (Manual) on 300 Series B Excavators
{7304}
Media Number -REHS2618-02 Publication Date -17/10/2008 Date Updated -17/10/2008

i03329120

Installing the 266-8480 Temperature Control Kit (Manual) on


300 Series B Excavators{7304}
SMCS - 7304

Excavator:
320B (S/N: 7JR1-878; 1XS1-633; 2AS1-570; 5MS1-318; 9WS1-178; 6LW1-233; 3YZ1-UP)
322B (S/N: 1YS1-761; 2ES1-403)
325B (S/N: 6DN1-632; 8FN1-511; 2JR1-1740,1741-1742; 4DS1-157; 5BS1-219)
330B (S/N: 3YR1-611; 5LR1-353; 6DR1-2009; 4RS1-360; 5LS1-210)

Introduction
This Special Instruction details the procedures to be used in order to replace the electronic components
in the Heater or Air Conditioner Groups for the listed machines.

Do not perform any procedure that is outlined in this publication, or order any parts until you have read
the information in this publication.

Refer to the appropriate Parts Manual, Operation and Maintenance Manual, and Service Manual for your
machine.

Required Parts
Table 1

Required Parts
Item Quantity Part Number
1 1 266-8480 Kit (Manual Controls)
2 1 205-4285 Electrical Converter Gp

https://sisweb.cat.com/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sis... 6/5/2010
330B L Excavator 6DR00001-UP (MACHINE) POWERED BY 3306 Engine(SEBP2437... Page 2 of 25

Note: Do not order the parts in Table 2. Parts in Table 2 are included in the 266-8480 Manual Control
Kit .

Table 2

Contents of 266-8480 Manual Control Kit


Item Quantity Part Number Label
1 1 271-1594 Control Gp
2 1 273-2808 Water Valve
3 3 245-1596 Actuator
4 1 271-1596 Bracket As
5 2 8T-0337 Screw
6 2 4B-4274 Washer
7 1 271-1593 Harness As
8 10 3S-2093 Cable Strap
9 1 239-9368 Resistor (27K)

Preparing The Machine for Servicing


Note: Before you begin the following procedure, swing the upper structure in order to gain access to the
panel that is located under the cab. This will allow access to the electrical connection for the ambient air
temperature sensor.

1. Park the excavator on level ground.

https://sisweb.cat.com/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sis... 6/5/2010
330B L Excavator 6DR00001-UP (MACHINE) POWERED BY 3306 Engine(SEBP2437... Page 3 of 25

Illustration 1 g00100836

2. Lower the boom until the bucket is flat on the ground and the stick is vertical. Refer to Illustration
1.

3. Shut off the engine and place the key in the ON position.

4. Place the hydraulic activation control lever in the UNLOCKED position.

5. Move the implement control levers in all directions in order to relieve any pressure that might be
present in the pilot system.

6. Return the key to the OFF position.

7. Make sure that the battery disconnect switch is in the OFF position.

https://sisweb.cat.com/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sis... 6/5/2010
330B L Excavator 6DR00001-UP (MACHINE) POWERED BY 3306 Engine(SEBP2437... Page 4 of 25

Illustration 2 g01053990
Example

8. Close the valves for the heater hoses in the engine compartment.

Removing the Storage Box and the Covers (Cab)


Note: The components in your machine may not appear to be identical with the components in the
following photographs. The photographs should be referenced as typical configurations.

1. Place the operator's seat in the full forward position.

Illustration 3 g00573876

2. Remove four screws (1) .

https://sisweb.cat.com/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sis... 6/5/2010
330B L Excavator 6DR00001-UP (MACHINE) POWERED BY 3306 Engine(SEBP2437... Page 5 of 25

Illustration 4 g00573879

3. Open the storage box. Disconnect two wires from 12 V socket (3), if the socket exists. Remove
four screws (2). Remove cover (4) .

Illustration 5 g00577139

4. Remove two screws (5). Remove screen (6) and the filter.

Illustration 6 g00577143

5. Remove two screws (7) and the plates. Remove cover (8) .

https://sisweb.cat.com/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sis... 6/5/2010
330B L Excavator 6DR00001-UP (MACHINE) POWERED BY 3306 Engine(SEBP2437... Page 6 of 25

Illustration 7 g00574475

6. Remove bolt (11) and the washer. Disconnect relay (15). Remove relay (15). Remove grommet
(16). Feed wire harness (12) through the box assembly. Feed wire harness (18) through the box
assembly.

7. Loosen two clamps (10). Remove fresh air duct (13). Remove two bolts (17), the nuts, and the
washers. Remove bracket (14). Remove four bolts (9) and the washers.

Illustration 8 g00574479

8. Reposition box assembly (19) in order to access hose clamp (20). Loosen hose clamp (20).
Remove hose (21). Remove box assembly (19) .

https://sisweb.cat.com/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sis... 6/5/2010
330B L Excavator 6DR00001-UP (MACHINE) POWERED BY 3306 Engine(SEBP2437... Page 7 of 25

Illustration 9 g00637584

9. Remove two bolts (22) and the washers. Remove two bolts (23), the washers, and the spacers.

10. Remove plate (24). The weight of plate (24) is approximately 7 kg (15 lb.)

Illustration 10 g00637727

Note: Mark the location of the wire tie-wraps when the wraps are removed. The mark will
simplify reassembly.

11. Remove the wire tie wraps. Disconnect electrical connector (25). The connector is attached to the
ambient air temperature sensor. Pull the wire harness through the operator platform.

Removing The Components from the 128-9726 Cab Heater Gp

https://sisweb.cat.com/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sis... 6/5/2010
330B L Excavator 6DR00001-UP (MACHINE) POWERED BY 3306 Engine(SEBP2437... Page 8 of 25

Illustration 11 g00638237

1. Remove bolt (28) and the washer from upper air duct (27). Peel back two rubber gaskets (26) on
each side of the upper air duct (27). Remove upper air duct (27) .

Illustration 12 g00638239

2. Disconnect the electrical connectors (29) to the fresh air actuator and upper body actuator
mounted on the case assembly.

https://sisweb.cat.com/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sis... 6/5/2010
330B L Excavator 6DR00001-UP (MACHINE) POWERED BY 3306 Engine(SEBP2437... Page 9 of 25

Illustration 13 g00638267

3. Remove four bolts (31) and the washers. Retain the bolts and washers for reassembly. Remove top
case cover (30). Retain the top cover for reassembly.

Illustration 14 g01171432
The 128-9726 Cab Heater Gp showing parts to be removed.

https://sisweb.cat.com/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sis... 6/5/2010
330B L Excavator 6DR00001-UP (MACHINE) POWERED BY 3306 Engine(SEBP24... Page 10 of 25

(39) Fresh Air Actuator

(38) Upper Body Actuator

(32) Case Assembly-Retain for reassembly

(37) Water Valve with mounting bracket

(36) Harness Assembly

(35) Control Group

(34) Relays

(33) Under Seat Actuator

4. Remove the parts shown in Illustration 14 and retain all mounting screws, bolts, and washers for
later use during assembly.

Illustration 15 g01171458
View of LH console showing the Control Panel (40) and wiring harness (41) .

5. Remove the Control Panel (40) located on the LH console.

6. Remove the wiring harness (41) which connects the Control Panel (40) to the 131-3809 Cab
Heater Gp .

Installing the New Components Onto The 128-9726 Cab Heater


Gp

https://sisweb.cat.com/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sis... 6/5/2010
330B L Excavator 6DR00001-UP (MACHINE) POWERED BY 3306 Engine(SEBP24... Page 11 of 25

Illustration 16 g01171480
Installation of new Fresh Air Actuator and Upper Body Actuator onto the Case Assembly.

Secure the 245-1596 Actuator with the screws and washers retained during disassembly.

1. Install a 245-1596 Actuator (43) to the Upper Body Door. The Upper Body door will be in the
closed position when the 245-1596 Actuator is installed. Secure the Actuator with the screws and
washers retained during disassembly. Install a 245-1596 Actuator (42) to the Fresh Air Door. The
Fresh Air Door will be in the open position when the 245-1596 Actuator Actuator is installed.

Note: May need to rotate Fresh Air Door slightly closed to align Actuator mounting holes.

https://sisweb.cat.com/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sis... 6/5/2010
330B L Excavator 6DR00001-UP (MACHINE) POWERED BY 3306 Engine(SEBP24... Page 12 of 25

Illustration 17 g01171503

2. Install a 245-1596 Actuator (44) to the Under Seat Door. The Under Seat Door will be in the
closed position when the 245-1596 Actuator is installed. Secure the Actuator with the screws and
washers retained during disassembly.

Note: May need to rotate Under Seat Door slightly open to align Actuator mounting holes.

Illustration 18 g01171635

https://sisweb.cat.com/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sis... 6/5/2010

You might also like