Professional Documents
Culture Documents
Final Lab Task Fall2020
Final Lab Task Fall2020
Problem Statement
Part 1:
a) A clipper is a device that removes either the positive half (top half) or negative half
(bottom half), or both positive and negative halves of the input AC signal. Design a clipper
circuit using diodes, batteries, Sine wave generator and resistors. The circuit should
perform the following operation as shown below:
Where, Vmax = 10 V, VB1 = 2 V, VB2 = 3 V and frequency of sine wave is equal to 1 kHz.
b) Simulate this circuit in Proteus software and show results on oscilloscope screen of
Proteus screen.
Part 2:
Page |2
Invert and amplify the output of above circuit using an inverting amplifier. The gain of
amplifier will be equal to your group number.
Hint:
• If one component does not work in Proteus, you may choose same component
with different description from devices.
• Take care of Ground connections
• Apply +20 V and -20 V as supply voltages (VCC and –VCC or VEE) of Op-Amp.