Professional Documents
Culture Documents
Base Shear Resistance Calculation - R1
Base Shear Resistance Calculation - R1
Assumption:
- Base slab is infinitely stiff to distribute the base shear evenly to all the piles.
- For marine clay, the moment point of inflection for piles are at 5m below founding level.
5m
Check moment capacity:
1200 dia
2061 kNm,
12818 kN
1400 dia
3819 kNm,
18358 kN
Project Job no.
Kallang PCLTC XXX
1800 dia
10435 kNm,
19085 kN
Diaphragm
resistance
10 36 5
y direction:
equivalent UDL = 18833/50=177 kN/m
Diaphragm
resistance
50
Calculation: Shear Design for circular sections with plane (discrete) or Chk by - Rev. Author: AJG
spiral links to EN1992 (with UK NA) and Arup 2011 NST 04
- This spreadsheet does not check the longitudinal shear is adequate, in accordance with cl. DEFINITIONS
6.2.3(7) for the assumed cotθ.
- References are to BS EN1992-1-1, using the UK NA where applicable; listed as either the
clause, expression (in brackets), or table or figures as noted.. * following an expression
reference denotes where the expression is modified as per 2011 NST 04.
fck = 32 MPa
γC = 1.20 Table 2.1
Design Values
VEd = 0 kN 0.000 MN
MEd / MRd = 0.41
NEd = 0 kN (compression positive)
σcp = 0.00 MPa 0.000 MN
Calculation: Shear Design for circular sections with plane (discrete) or Chk by - Rev. Author: AJG
spiral links to EN1992 (with UK NA) and Arup 2011 NST 04
- This spreadsheet does not check the longitudinal shear is adequate, in accordance with cl. DEFINITIONS
6.2.3(7) for the assumed cotθ.
- References are to BS EN1992-1-1, using the UK NA where applicable; listed as either the
clause, expression (in brackets), or table or figures as noted.. * following an expression
reference denotes where the expression is modified as per 2011 NST 04.
fck = 32 MPa
γC = 1.20 Table 2.1
Design Values
VEd = 0 kN 0.000 MN
MEd / MRd = 0.41
NEd = 0 kN (compression positive)
σcp = 0.00 MPa 0.000 MN
Calculation: Shear Design for circular sections with plane (discrete) or Chk by - Rev. Author: AJG
spiral links to EN1992 (with UK NA) and Arup 2011 NST 04
- This spreadsheet does not check the longitudinal shear is adequate, in accordance with cl. DEFINITIONS
6.2.3(7) for the assumed cotθ.
- References are to BS EN1992-1-1, using the UK NA where applicable; listed as either the
clause, expression (in brackets), or table or figures as noted.. * following an expression
reference denotes where the expression is modified as per 2011 NST 04.
fck = 32 MPa
γC = 1.20 Table 2.1
Design Values
VEd = 0 kN 0.000 MN
MEd / MRd = 0.41
NEd = 0 kN (compression positive)
σcp = 0.00 MPa 0.000 MN