Professional Documents
Culture Documents
CR Pump Ford Замены
CR Pump Ford Замены
CR Pump Ford Замены
TECHNICAL
JAN 2009
COMMERCIALLY CONFIDENTIAL DT402/2(EN)
1. INTRODUCTION
As the result of a request from Ford, all of the existing range of pumps with 0.9cc/rev capacity,
fitted to the Puma range of engines, including the early pumps fitted with tin plated Fuel
Temperature Sensor (FTS) connectors, are now serviced by a range of pumps having 1.2cc/rev
capacity.
The existing pumps have been replaced by the new versions according to the list below:-
9044A031A
9044A032A
9044A033A
9044A035B
9044A034A 9044A130A 9044A130A
9044A035A
9044A100A 9044A090A N/A
9044A080A 9044A090A N/A
Pumps 9044A130A & B retain the original ‘stud’ type inlet connection, 9044A090A has the ‘swept
pipe’ type connection.
In addition these changes have also been implemented for the Independent Aftermarket, i.e. only
the 1.2cc variants are available for service.
The 1.2 CC pumps are interchangeable with the 0.9CC versions, however, the 0.9CC versions
must not be used to replace the 1.2CC.
DELPHI Diesel Systems Ltd, Diesel Aftermarket, Spartan Close, CV34 6AG, Warwick, England.
Tel: [44] [0] 1926 472 900 Fax: [44] [0] 1926 472 901 © Delphi
DT402/2(EN) - JAN 2009 - 2 of 2
2. SERVICE ACTION
As a further result of this change the 0.9cc drive shaft part number 9303-520B is longer being
produced, and thus, once stocks are exhausted, any pumps received for service and requiring a
new driveshaft must be upgraded to the 1.2cc version (part number 9303-520D).
In addition to the change of driveshaft, the TP regulator device must also be upgraded to the version
with the integral damper (kit part number 7135-480).
The pump number must then be amended, according to the table above, to reflect this change,
and the modified pump must then be tested to the relevant testplan.