Professional Documents
Culture Documents
MCQ in Wire and Wireless Communications System Part 7 ECE Board
MCQ in Wire and Wireless Communications System Part 7 ECE Board
MCQ in Wire and Wireless Communications System Part 7 ECE Board
7 | ECE Board
pinoybix.org/2014/12/mcqs-in-wire-and-wireless-communications-system-part7.html
This is the Multiples Choice Questions Part 7 of the Series in Wire and Wireless
Communications System as one of the Communications Engineering topic. In Preparation
for the ECE Board Exam make sure to expose yourself and familiarize in each and every
questions compiled here taken from various sources including but not limited to past
Board Examination Questions in Electronic System and Technologies, Communications
Books, Journals and other Communications References.
A. user or caller
B. cell site
C. called party
D. MTSO
View Answer:
Answer: Option D
Solution:
A. 250 kHz
B. 200 kHz
C. 150 kHz
D. 100 kHz
2/20
View Answer:
Answer: Option B
Solution:
303. A switching facility connecting cellular telephone base stations to each other and to
the public switched telephone network.
A. MTSO
B. MSC
C. VLR
D. AuC
View Answer:
Answer: Option B
Solution:
A. land station
C. base station
D. mobile station
View Answer:
Answer: Option C
Solution:
305. Transmission of brief text messages, such as pages or e-mail, by cellular radio or PCS.
A. SMS
B. MMS
C. paging
D. raking
3/20
View Answer:
Answer: Option A
Solution:
306. The point when the cell reaches maximum capacity occurs when the number of
subscribers wishing to place a call at any given time equals the number of channels in the
cell
A. saturation
B. blocking traffic
D. any of these
View Answer:
Answer: Option C
Solution:
307. In IS-41 standard, it is a process where the mobile unit notifies a serving MTSO of its
presence and location through a base station controller.
A. dependent registration
B. autonomous registration
C. air interface
View Answer:
Answer: Option B
Solution:
A. simplex
B. half-duplex
4/20
C. full-duplex
D. triplex
View Answer:
Answer: Option C
Solution:
309. A receiver capable of receiving several versions of the same signal with different
arrival times and combining the received versions into a single signal with better quality
A. scanners
B. rake receivers
D. mobile stations
View Answer:
Answer: Option B
Solution:
A. VLR
B. HLR
C. BTS
D. AUC
View Answer:
Answer: Option B
Solution:
311. In CMTS, the number of duplex voice channels for AMPS is ____.
A. 676
B. 285
5/20
C. 395
D. 790
View Answer:
Answer: Option C
Solution:
312. A geographic cellular radio coverage area containing three of more group of cells
A. cluster
B. cell
C. radio channel
D. MSC/VLR area
View Answer:
Answer: Option A
Solution:
A. hard handoff
B. soft handoff
C. heavy handoff
D. light handoff
View Answer:
Answer: Option B
Solution:
A. 32
B. 15
6/20
C. 10
D. 8
View Answer:
Answer: Option B
Solution:
315. The RF power output of a transmitter in a cellular mobile telephone system authorized
by NTC for use in the Philippines.
A. 20.5 dBm
B. 31.5 dBm
C. 34.8 dBm
D. 22.1 dBm
View Answer:
Answer: Option D
Solution:
A. 4 W
B. 1.6 W
C. 600 mW
D. 1.4 W
View Answer:
Answer: Option C
Solution:
317. ____ is measuring the propagated field strength over the projected service area.
A. radio monitoring
B. radio sounding
7/20
C. radio survey
D. none of these
View Answer:
Answer: Option C
Solution:
318. Transmission of data in two directions on a channel by using different time slots for
each directions.
A. time-division multiplexing
C. time-division duplexing
D. time-division
View Answer:
Answer: Option C
Solution:
319. When the cluster size is reduced with a constant cell size, what happens to the total
channel capacity?
A. decreases
B. increases
C. stays constant
View Answer:
Answer: Option B
Solution:
320. The transfer of a mobile unit from one base station’s control to another base station’s
control
8/20
A. handoff
B. paging
C. roaming
D. dualization
View Answer:
Answer: Option A
Solution:
A. 12 kHz
B. 6 kHz
C. 3 kHz
D. 18 kHz
View Answer:
Answer: Option A
Solution:
A. 2
B. 3
C. 4
D. 5
View Answer:
Answer: Option A
Solution:
323. A transmit channel has a frequency of 837.6 MHz. The receive channel frequency is
9/20
A. 729.6 MHz
B. 837.6 MHz
C. 867.6 MHz
D. 882.6 MHz
View Answer:
Answer: Option D
Solution:
A. 0.2 sec/hop
B. 0.4 sec/hop
C. 0.3 sec/hop
D. 0.1 sec/hop
View Answer:
Answer: Option D
Solution:
A. 128 kbps
B. 240 kbps
C. 64 kbps
D. 270 kbps
View Answer:
Answer: Option D
Solution:
10/20
326. A card with an embedded integrated circuit that can be used for functions such as
storing subscriber information for a PCS system.
A. smart card
B. SIM
C. Intelligent card
D. Credit card
View Answer:
Answer: Option A
Solution:
327. It is a means of avoiding full-cell splitting where the entire area would otherwise need
to be segmented into smaller cells.
A. segmentations
B. dualization
C. sectoring
D. splitting
View Answer:
Answer: Option B
Solution:
328. A channel used for transferring control and diagnostic information between mobile
users and a central cellular telephone switch through the base stations.
A. forward channel
B. voice channel
C. control channel
D. reverse channel
View Answer:
Answer: Option C
11/20
Answer: Option C
Solution:
329. It is the provision of voice communication using internet protocol technology, instead
of traditional circuit switched technology.
A. WAP
B. GPRS
C. VOIP
D. WIFI
View Answer:
Answer: Option C
Solution:
330. Determine the total number of channel capacity of a cellular telephone area
comprised of 10 clusters with seven cells in each cluster and 10 channels in each cell.
A. 7 channels
B. 70 channels
C. 700 channels
D. 7000 channels
View Answer:
Answer: Option C
Solution:
331. Technique used in spread spectrum that adds a high-bit rate pseudorandom code to a
low bit rate information signal to generate a high-bit rate pseudorandom signal closely
resembling noise that contains both the original data signal and pseudorandom noise.
A. direct-sequence
B. frequency-division multiplexing
C. frequency hopping
12/20
D. CDMA
View Answer:
Answer: Option A
Solution:
332. Refers to the first generation of local loop system in telecommunication technology
A. TACS
B. DECT
C. Analog cellular
D. GSM
View Answer:
Answer: Option C
Solution:
333. An information sent by the base station in a cellular radio system set the power level
of the mobile transmitter.
View Answer:
Answer: Option C
Solution:
334. A 32-bit binary code permanently assigned to each of the mobile unit
View Answer:
Answer: Option C
Solution:
335. It serves as central control for all users within that cell
A. base stations
B. antennas
C. transceivers
View Answer:
Answer: Option A
Solution:
336. What modulation technique is used by Advanced Mobile Phone System (AMPS)
A. WBFM
B. VSB
C. NBFM
D. FSK
View Answer:
Answer: Option C
Solution:
337. A database in the PCS network that stores information about subscribers in a
particular MTSO serving area
View Answer:
Answer: Option B
Solution:
338. In cellular phone, a memory location that stores the telephone number(s) to be used
on the system.
A. EPROM
B. UVPROM
C. EEPROM
D. NAM
View Answer:
Answer: Option D
Solution:
339. A province in the Philippines has an area 2000 sq. kms. It has to be covered by a
cellular mobile telephone service using cells with a radius of 3 kms. Assuming hexagonal
cells, find the number of cell sites needed.
A. 100
B. 500
C. 166
D. 145
View Answer:
Answer: Option D
Solution:
A. QAM
15/20
B. Phase Shift Keying
View Answer:
Answer: Option C
Solution:
A. 0.4 W to 0.7 W
B. 1 W to 6 W
C. 0.5 W to 8 W
D. 0.1 W to 1 W
View Answer:
Answer: Option D
Solution:
342. Determine the receive carrier frequencies for AMPS channel 3 and channel 991
View Answer:
Answer: Option A
Solution:
A. clustering
16/20
B. splitting
C. partitioning
D. sectoring
View Answer:
Answer: Option D
Solution:
A. 400 ms
B. 300 ms
C. 200 ms
D. 100 ms
View Answer:
Answer: Option C
Solution:
345. Component of a cellular telephone network that manages each of the radio channels at
each site.
View Answer:
Answer: Option A
Solution:
A. 4
17/20
B. 5
C. 8
D. 10
View Answer:
Answer: Option A
Solution:
347. The master control center for a cellular telephone system is the
A. Cell site
B. MTSO
C. Central office
D. Branch office
View Answer:
Answer: Option B
Solution:
A. 6 kHz
B. 12 kHz
C. 30 kHz
D. 45 kHz
View Answer:
Answer: Option B
Solution:
349. A receiver channel has a frequency is 872.4 MHz. to develop an 82.2 MHz IF, the
frequency synthesizer must apply an local oscillator signal of ____ (The local oscillator is
usually higher than the receive frequency)
18/20
A. 790.2 MHz
B. 827.4 MHz
C. 954.6 MHz
D. 967.4 MHz
View Answer:
Answer: Option C
Solution:
A. 6 dBW
B. 2 dBW
C. -2 dBW
D. -6 dBW
View Answer:
Answer: Option A
Solution:
Following is the list of multiple choice questions in this brand new series:
20/20