Professional Documents
Culture Documents
HW 2 ME307 141 Solution
HW 2 ME307 141 Solution
HW 2 ME307 141 Solution
Problem # 1(10 Marks) Use Integration method to derive the deflection equations (yAB, yBC and ymax) for
the following beam of Table A-9.
Hint: Use the bending moments equations MAB and MBC given above (or from A-9-2).
ME 307 Machine Design I HW # 02 (Due Date 19-10-2014) Spring Semester 2014-2015 (141)
King Fahd University of Petroleum & Minerals
College of Engineering Sciences
Mechanical Engineering Department
Problem # 2(15 Marks): A rectangular steel bar supports the two overhanging loads shown in the figure. Using
superposition, find the deflection at the ends and at the center.
ME 307 Machine Design I HW # 02 (Due Date 19-10-2014) Spring Semester 2014-2015 (141)
King Fahd University of Petroleum & Minerals
College of Engineering Sciences
Mechanical Engineering Department
ME 307 Machine Design I HW # 02 (Due Date 19-10-2014) Spring Semester 2014-2015 (141)
King Fahd University of Petroleum & Minerals
College of Engineering Sciences
Mechanical Engineering Department
Problem # 3(25 Marks): Solve Problem 4-42 (textbook) using Castigliano’s theorem.
ME 307 Machine Design I HW # 02 (Due Date 19-10-2014) Spring Semester 2014-2015 (141)
King Fahd University of Petroleum & Minerals
College of Engineering Sciences
Mechanical Engineering Department
Problem # 4(15 Marks): The Figure below shows a 1in dia steel bar supported and subjected to the
applied load P = 500 lb. Solve for the deflection at the load and the slope at the roller support.
ME 307 Machine Design I HW # 02 (Due Date 19-10-2014) Spring Semester 2014-2015 (141)
King Fahd University of Petroleum & Minerals
College of Engineering Sciences
Mechanical Engineering Department
ME 307 Machine Design I HW # 02 (Due Date 19-10-2014) Spring Semester 2014-2015 (141)
King Fahd University of Petroleum & Minerals
College of Engineering Sciences
Mechanical Engineering Department
ME 307 Machine Design I HW # 02 (Due Date 19-10-2014) Spring Semester 2014-2015 (141)
King Fahd University of Petroleum & Minerals
College of Engineering Sciences
Mechanical Engineering Department
Simple
Support Roll OD
Roll ID
Press Roll
Simple
Support
Hollow Shaft
ME 307 Machine Design I HW # 02 (Due Date 19-10-2014) Spring Semester 2014-2015 (141)
King Fahd University of Petroleum & Minerals
College of Engineering Sciences
Mechanical Engineering Department
ME 307 Machine Design I HW # 02 (Due Date 19-10-2014) Spring Semester 2014-2015 (141)
King Fahd University of Petroleum & Minerals
College of Engineering Sciences
Mechanical Engineering Department
ME 307 Machine Design I HW # 02 (Due Date 19-10-2014) Spring Semester 2014-2015 (141)