The document contains 3 technical drawing questions:
1) Draw a shear plate layout at a scale of 1:2 using geometric methods to construct angles and state the length of side KA.
2) Construct a triangle where the sides are in proportion of 5:7:9 and the perimeter is 270mm, and also construct and measure the circumscribing circle.
3) Draw a triangle given that the base is 100mm, one base angle is 48 degrees, and the sum of the two remaining sides is 235mm.
The document contains 3 technical drawing questions:
1) Draw a shear plate layout at a scale of 1:2 using geometric methods to construct angles and state the length of side KA.
2) Construct a triangle where the sides are in proportion of 5:7:9 and the perimeter is 270mm, and also construct and measure the circumscribing circle.
3) Draw a triangle given that the base is 100mm, one base angle is 48 degrees, and the sum of the two remaining sides is 235mm.
The document contains 3 technical drawing questions:
1) Draw a shear plate layout at a scale of 1:2 using geometric methods to construct angles and state the length of side KA.
2) Construct a triangle where the sides are in proportion of 5:7:9 and the perimeter is 270mm, and also construct and measure the circumscribing circle.
3) Draw a triangle given that the base is 100mm, one base angle is 48 degrees, and the sum of the two remaining sides is 235mm.
The document contains 3 technical drawing questions:
1) Draw a shear plate layout at a scale of 1:2 using geometric methods to construct angles and state the length of side KA.
2) Construct a triangle where the sides are in proportion of 5:7:9 and the perimeter is 270mm, and also construct and measure the circumscribing circle.
3) Draw a triangle given that the base is 100mm, one base angle is 48 degrees, and the sum of the two remaining sides is 235mm.
1. The layout of a shear plate is shown in the figure below.
(a) Draw the layout of the plate using scale 1:2. Where possible use
geometrical methods of constructing angles.
(b) State the length of side KA.
2. The sides of a triangle are in a proportion of 5 : 7 : 9 and the perimeter is
270mm. Construct the triangle and the circumscribing circle of it. Measure and state the lengths of sides of the triangle and the diameter of the circle.
3. Draw a triangle having been given the following data: