Webasto T91 Installation Manual

You might also like

Download as pdf or txt
Download as pdf or txt
You are on page 1of 4

VW Amarok 2H0

Webasto Telestart Installation Manual


v. 1.0.

Included:
1 pcs Webasto T91 - Receiver
1 pcs Webasto T91 - Key FOB
1 pcs Antenna
1 pcs Cable Set
1 pcs Installation Kit
1 pcs Webasto Holder

www.carsystems.eu
Downloaded from www.Manualslib.com manuals search engine
VW Amarok- Webasto Telestart Installation Manual

1 2
Preheater Location. There is a GND / ground point under the
carpet, screw down the brown connectorhere.

Wiring harness pass through


1 Protective rubber plug
2 Wiring harnesses of heater, heater control

2 www.carsystems.eu

Downloaded from www.Manualslib.com manuals search engine


VW Amarok- Webasto Telestart Installation Manual

3 4
Remove plug from webasto heater. Insert white connector (wire with terminal and
Slide green security bolt. seal at end) into 1 pin hole. Tie the wire as
original installation.

5 6
Put in telestart module, insert blue plug and U can put in antenna on the plastic cover of
antenna plug. the driver seat.
Fasten bracket 3 on M5x16 bolt 2
1 Receiver

3 2 1

www.carsystems.eu
3
Downloaded from www.Manualslib.com manuals search engine
VW Amarok- Webasto Telestart Installation Manual

7
Before parking the vehicle, make the following
settings:
1 Set temperature to "max."
2 Air outlet to windscreen
3 Set fan to level "1", or possibly "2"

4 www.carsystems.eu

Downloaded from www.Manualslib.com manuals search engine

You might also like