Professional Documents
Culture Documents
Nport 5110 Quick Installation Guide: 3. Hardware Introduction
Nport 5110 Quick Installation Guide: 3. Hardware Introduction
Hardware Introduction LED Indicators—NPort 5110’s top panel has three LED indicators, as
As shown in the following figures, NPort 5110 has one male DB9 port for described in the following table.
NPort 5110 transmitting RS-232 serial data.
LED LED
LED Function
Quick Installation Guide Rear Panel View Name Color
Steady on: Power is on and NPort is booting up.
Third Edition, November 2005 red Blinking: Indicates an IP conflict, or DHCP or
RJ45 10/100M Ethernet port
BOOTP server is not responding
properly.
Reset button
Steady on: Power is on and NPort is functioning
1. Overview Power input Ready
normally.
NPort 5110 is a compact, palm-sized data communication device that Top Panel View green Blinking: The NPort has been located by
allows you to control RS-232 serial devices over a TCP/IP-based RESET 10/100M NPort Administrator’s Location
9-30VDC Ethernet
Ethernet. function
off Power is off, or power error condition exists.
Note: orange 10 Mbps Ethernet connection.
“-T” indicates an extended temperature model. DIN-Rail
screw hole Link green 100 Mbps Ethernet connection.
toothpick, to press the reset button. This will cause the Ready LED to desktop or other
blink on and off. The factory defaults will be loaded once the Ready LED horizontal surface, you
may also make use of
stops blinking (after about 5 seconds). At this point, you should release
the DIN-Rail or Wall
the reset button. Mount options, as 5110
Ready
Link
Tx/Rx
Port 1 RS-232
P/N: 1802002010500
1 5
6 9