Screenshot 2021-04-07 at 2.10.43 PM

You might also like

Download as pdf or txt
Download as pdf or txt
You are on page 1of 95

Scanned by CamScanner

Scanned by CamScanner
Scanned by CamScanner
Scanned by CamScanner
Scanned by CamScanner
Scanned by CamScanner
Scanned by CamScanner
Scanned by CamScanner
Scanned by CamScanner
1. Which one of the engineering characteristics can best explain the following concept? Base
your decision on reason rather than emotions.
A. Quantitative Thinking.
B. Interpersonal skill.
C. Honesty.
D. Logical thinking.

2. The most economical method of starting a single phase motor is?


A. Split-phase method
B. Resistance start method
C. Inductance start method
D. Capacitance start method

3. In HDL Based digital systems the arithmetic multiplication function is difficult to


synthesize. Design solution to this challenge do not include:
A. Sequential generation of partial products
B. Hardware intensive simultaneous generation of partial products
C. Implementation of booths algorithm to minimize generation of partial products
D. Sequential right shifts of the arguments

4. The wind load Lsi In newton s on an overhead line structure is calculated using the following
formula. Lsi = 0.613V2 m/s Kz GRF ICf Am 2
What does the Kz term represent?
A. Force coefficient
B. Guest response Factor
C. Velocity pressure coefficient
D. Wind speed

5. The self-discharge rate of a lead-acid battery is least dependent on which of the following
factors?

6. A digital signal processor (DSP) is designed to perform FFT operations for a digital
oscilloscope that utilizes a 12-bit A/D converter. the most cost effective ALU architecture
for this CPU is a:
A. Fixed-point multiplier with an 8-bit data path
B. Floating-point multiplier with an 8-bit data path
C. Fixed-point multiplier with a 16-bit data path
D. Floating-pointing multiplier with a 16-bit data path

7. Which of the fallowing characteristics of a data network is never a correct of a


packet-switched network?
A. A transmitted packet contains source and destination address coding, information, and
error control bits.
B. Individual packets of a long message can be routed under different paths by the
switching exchange equipment.
C. The address coding is transparent to a user
D. A transmitted packet contains only information bits.

8. An engineer is offered some additional gifts and services in exchange for using superior
materials on a remodelling project. This was not detailed in the contract. He should:
A. Take the offer and use the special materials
B. Reject the offer
C. Ask her boss which of the gifts to accept
D. Accept the gifts but use the materials specified in the contract in order to retain
neutrality.

9. In the receiver of a wireless system, we must amplify the received signal using.
A. Power amplifier
B. Differential amplifier
C. An active filter
D. A low-noise amplifier

10. A low-pass filter is used to


A. Stop low frequencies
B. Pass a band of frequencies
C. Stop high frequencies
D. Stop a band of frequencies

11. Dynamic power consumption on advanced system on chip can go up to:


A. 80%
B. 50%
C. 10%

12. The interdisciplinary nature of engineering has implications for the appropriateness of
specialization. Which of the fallowing is correct?
A. Since all engineering projects are interdisciplinary, all engineers should be expert in all
fields of engineering.
B. The interdisciplinary nature of engineering means that all engineers should study
gene al enginee ing a he han pecialize in a single area.
C. Most engineers will wish to specialize, but all engineers must be able to work
effectively alongside others with complementary skills.

13. This is a type of semiconductor that only allows current to flow in one direction. It is usually
used to rectify AC signals (conversion to DC).
A. Diode
B. Transformer
C. Inductor

14. The noise margins of an inverter with VOH=3 V, VH=2V, VOL=0.5V, VIL=0.8V is
A. NMH=1V, NML=1.5V
B. NMH=0.3V, NML=1V
C. NMH=2.2V, NML=0.3V
D. NMH=1V, NML=0.3V

15. The unit of current is


A. Ampere
B. Watt
C. Volt
D. An o her ri e here).

16. The unit of conductance is:


A. Per ohm
B. Ohm/m
C. Mho/m
D. Mho

17. In conducting a power-flow (or load-flow) study using conventional iterative calculations,
which of the fallowing statements is most nearly correct?
A. One bus is designated as a slack bus, and the others are designated as voltage-controlled
buses or load buses.
B. One bus is designated as a voltage-controlled bus, and the others are designated as slack
buses or load buses.
C. One bus is designated as a load bus, and the others are designated as voltage-
controlled buses or slack buses.
D. There may be any number of slack busses, voltage-controlled buses, and load
buses designated, as long as they total the number of buses in the network.

18. What does pipelining?


A. Latency
B. Throughput
C. Both

19. Which of the fallowing would not be classified as direct cost?


A. Safety and first aid expenses.
B. Finishing labor for a concrete slab.
C. Materials for a structural steel frame.
D. Foundation excavation equipment expenses.

20. The equivalent circuit of induction machine at no load is the same as that of the transformer
but with
A. Open circuited secondary.
B. Short circuited secondary.
C. Open circuited primary.
D. Short circuited primary.

21. Three 30-µF capacitors are connected in star (Y) form between the terminals A, B, C and a
junction point N as shown in the figure, the capacitance (µF) between terminals A and B is
most nearly.

A. 2/30
B. 15
C. 30
D. 60
E.
22. The output D in the circuit is.

A. B(A+C)
B. (A+B) (B+C)

23. Which of the fallowing types of material has high thermal and electrical conductivity?
A. Ceramic
B. Metal
C. .( Any other write here)

24. For the diagram shown, what is the approximate required minimum clearance distance, R, if
the phase voltage of the live parts is 13,800 V?

A. 1.8 m
B. 2.5 m
C. 3 m
D. 4 m

25. The accreditation board for engineer and technology (ABET) is an accrediting agency for.
A. Engineering education programs.
B. Engineering fundamentals examinations.
C. Engineering firms.
D. All of the above.

26. In 50Hz induction machine, if the no load speed is 745 r.p.m, the synchronous speed is
A. 700 rpm.
B. 750 rpm.
C. 800 rpm.
D. 850 rpm.

27. Which one is the harmonic source in the fallowing list.


A. Variable impendence loads.
B. Saturable magnetic loads.
C. Power electronic based loads.
D. All of the above.
Scanned by CamScanner
Scanned by CamScanner
Scanned by CamScanner
Scanned by CamScanner
Scanned by CamScanner
Scanned by CamScanner
Scanned by CamScanner
Scanned by CamScanner
Scanned by CamScanner
Scanned by CamScanner
Scanned by CamScanner
Electrical-4

1) A super heterodyne AM receiver within an intermediate frequency (IF) Of 455 kHz is to be turned to listen to
a station at 540 kHz. What tuning frequency is used in the local oscillator?
a) 96 kHz
b) 540 kHz
c) 550 kHz
d) 995 kHz

2) The out put is to be maintained at 24v while the input varies from 120 v to 126 v with a load current ranging
from 0 A to 3A . Assume ideal conditions that is the keep alive current its zero and the zero resistance R is
negligible.

What is the required supply resistance to ensure proper operation of the zenar regulator circuit.
a) 19
b) 22
c) 24
d) 25

3) Which of the following regression models is not considered to be linear regression model for predicting Y in
terms of X?

4) When a fuse is rated 8A, it means

a) It will not work if current is less than


b) Is has a resistance of 8 W
c) It will work only if current is 8 A
d) It will melt if current exceeds 8 A
5) We have three resistances of values 2 , 3 , 6 . Which f he f ll ing c mbina i n will give an
effective resistance of 4
a) All the three resistance in parallel
b) 2 resistance in series with parallel combination of 3 and 6 resistance
c) 3 resistance in series with parallel combination of 2 and 6 resistance

6) For which of the following topologies can 10 base not be used without additional hardware conversion?
a) Star
b) Tree
c) Point to point
d) Bus

7) In transformer saturation
a) The efficiency decreases and the no load current increases
b) The efficiency decreases and the no load current decreases
c) The efficiency increases and the no load current increases
d) The efficiency increases and the no load current decreases

8) The assembly language is usually used for programming


a) DSP
b) MICRO CONTROLLERS
c) FPGA

9) In a typical computer architecture the minimum set of registers necessary for general operation will include
a) Accumulation general register one and two
b) Accumulation general register one and two instruction register ,memory address register, memory
buffer register, program register
c) Accumulator memory address register, memory buffer register , program counter
d) Accumulator, instruction register, memory address register, memory buffer register, program counter

10) The OP-AMP circuit shown performs the function of

a) Amplification
b) Integration
c) Dimension
d) Simming
e) Attenuation

11) a basic time domain reflectometry (TDR) system is used with an oscilloscope to display the waveform at
the input end of a line in a non-return-zero (NRZ) digital system
a 1000 m cable is terminated with a short circuit at the far end , the first reflected wave appears 9.43
µs the incident waveform. The actual velocity in the cable divided by the speed of light is v =2 /T
a) 0.35
b) 0.71
c) 1.0
d) 1.41

12) An antenna has an effective aperture of 10 m². What additional information is required to determine the
amplifier power ?
a) Power destiny
b) Power loss
c) Space loss
d) Total aperture
Electrical 5

1) Splitting project into tasks and estimate time and resources required to complete each task is called
a) project scheduling
b) project optimization
c) project control
2) the OP-AMP circit shown performs the function of

a) simplification
b) integration
c) differentiation
d) summing
e) attenuation
3) a copper cable used in a plain old telephone service line has a loss of 1.5 dB/km. What is the
approximate loss experienced if the user is located 1.5km from the central office?
a) 1.5 dB
b) 15 dB
c) 20 dB
d) 220 dB
4) A lossy transmission line is used to connect a transmitter to an antenna. If the VSWR measured at
the antenna end tof the transmission line is 1.5. which of the following statements is correct?
a) The VSWR measured at the transmitter end of the transmission line is smaller than 1.5.
b) The VSWR measured at the transmitter end of the transmission line is greater than 1.5.
c) The VSWR measured at the transmitter end of the transmission line is equal 1.5.
d) The characteristic impedance of the antenna matches exactl the characteristic impedance of the
transmission line

5) A motor is equipped with an optical shaft encoder to measure motor speed. The optical encoder provides
200 pulses per motor revolution. A microcontroller equipped with a real-time interrupt (RTI)capability is
used to measure motor speed. The RTI interval is 32.768 ms. The microcontroller counts 372 pulses from
the optical encoder in the RTI interval. The speed rpm of the motor is
a) 33
b) 568
c) 3276
d) 3400
6) Referring to the figure the voltage V across till: 50-U resistor is :
Hint: ω=2 f
a) 35
b) 51
c) 71
d) 92
7) Software maintenance activities can be classified into several maintenance types. Which of the
following is not a soft ware maintenance type
a) Adaptive maintenance
b) Corrective maintenance
c) Customer-initiated maintenance
d) Perfective maintenance
8) Your boss has just approved the initiationof a project to celebrate Qatara TMS a i al da adia
has been assigned the project manger as should be
a) Establish the reporting process to the boss
b) Work on the project scope
c) Make a report on reqired cost for the project
d) Develop the project charter to do the project
e) Ask the boss as to how many team members would be allowed in the project
9) With respect to relational record based data models at the user level, a relation is represented in a
a) Key
b) List
c) Queue
d) Table
10) In optical communication frequency division multiplexing (FDM ) is called?
a) Polarization-division multiplexing (PDM)
b) Space-division multiplexing (SDM)
c) Single-sideband modulation (SSB)
d) Wavelength division multiplexing (WDM)
11) In the receiver of a wireless system we must amplify the received signal using
a) A power amplifier
b) A differential amplifier
c) An active filter
d) A low noise amplifier
12) Of the following wngineering disciplines, who would be BEST suited to design and operate an automobile
factory
a) Petroleum engineer
b) Mechanical engineer
c) Civil engineer
d) Chemical engineer
13) If the souce voltge in the circuit shown is v = 100sin 377t, the peak reverse voltage applied to the diode
would
14) A room with a floor area of 50ft × 30ft and a ceiling height of 10 ft has luinaires suspended 2 ft from the
ceiling. Assuming a working plane of 30 in and a reqired illumination levelof 50 fc, the net luminous flux
(lumens) using fixtures with a coefficient of utilization of 0.78 is most nearly
a) 48000
b) 58000
c) 75000
d) 96000
15) Increasing the current withdrawn from a battery has what effect on the battery capacity and why?
a) Increased capacity which is cased by less internal hear loss
b) Increased capacity which is caused by lower internal resistance
c) Decreased capacity which is caused by higher load voltage drop
d) Decreased capacity which is caused by increased polarization
16) Consider the oscillator circit shown below. This circuit uses which resonsnt mode (s) of the crystal XI
a) Serries resonant
b) Parallel resonant
c) Series-parallel resonant
d) Not resonant
17) The resistance of 100 W , 200 V tamp is

a) 100 ohm
b) 200 ohm
c) 400 ohm
d) 1600 ohm
18) A de current of 50 A is flowing ina long isolated wire. The magnitude of the magnetic field intensity.
H(A/m), 10 cm from the center of the wire is
a) 0.05
b) 8
c) 43
d) 80
19) Which of the following chices is not one of the stages of a project life cycle?
a) Concept
b) Initiation
c) Planning
d) Execution
e) Delivery / closure
20) The main cause for transformer humming is
a) Vibrations in the insulating and cooling oil
b) Vibrations int he core laminations
c) Vibrations in the bushes
d) None of the above
21) Ina cascade amplifier, to reduce the loading effect at the output the output impedance of the last stage
should be
a) Very high
b) Intermediate
c) Very small
22) While machine operation, the slip of the symchronous machine is a a
a) High
b) Low
c) Zero
d) One
23) Field-programmable gate arrays (FPGAs) and other array logic devices normally contain numerous
flip flops. These flip-flops are generally of the type
a) D
b) J-K
c) S-R
d) T
24) Which of the following statements does not represent ohm s la
a) Current / potential difference = constant
b) Potential difference / current = constant
c) Potential difference = current × resistance
d) Current = resistance × potential difference
25) Strength of material may be defined as
a) The maximum internal resistance offered by the materials to the externally applied force
b) Capability of materials to absorb strain energy
c) Capability of materials to do work
d) The maximum internal resistance offered by the materials against deformation
26) The spinning reserve is the
a) Generating capacity that is connected to the grid and ready to take the load
b) Generating capacity that is available for service but ot in operation
c) Generating capacity under maintenance
d) None of the above
Elec 6

1) Field-programmable gate arrays (FPGAs) and other array logic devices normally contain numberous
flip-flops. These flip-flops are generally o the type
a) D
b) J-K
c) S-R
d) T
2) A 3-PHASE, 60-Hz induction motor has a nameplate speed of 1600 rpm. This motor has how many
poles
a) 2.0
b) 4.0
c) 6.0
d) 8.0
3) The output is to be maintained at 24 V, while the input varies from 120 V to 126 V with a load current
ranging from 0A to 5A . Assume ideal conditions, that is the keep alive current is zero and the
zener resistance RZ is negligible

Useful relationships: RS = (Vin,min VZM ) / IL,MAX PD = IZ,MAX VZM PRS = I²Z,MAX RS


What is the minimum power of the supply resistor?
a) 400
b) 450
c) 500
d) 550
4) In the receiver of a wireless system, we must amplify the received signal using
a) A power amplifier
b) A differential amlifirer
c) An active filter
d) A low-noise amplifier

5) The minimum standard wire guage of earth wire is


a) 20SWG
b) 16 SWG
c) 10 SWG
d) 8 SWG

6) Of the following engineering disciplines, who wold be BEST sited to desigb and operate an automobile
factory?
a) Petroleum engineer
b) Mechanical engineer
c) Civil engineer
d) Chemical engineer
7) Which of the following is a name for a set of indices and values?
a) Array
b) Stack
c) Queue
d) FIFO
8) While machine operation, the slip of the synchronous machine is
a) High
b) Low
c) Zero
d) 1
9) Scheduling periodic tasks to execute on a processor based on assigning the highest priority to the task that
has the shortest period(greatest frequency) is
a) Cyclic executive
b) Deadline monotonic
c) Earliest deadline first
d) Rate monotonic
10) The travelling crains are mostly travelled by
a) Ward leonard controlled DC shunt motor
b) AC slip ring motor
c) Synchronous motor
d) DC differentially compound motor
11) The resistance of a n electric bulb drawing 1.1 A current at 6.0 V is
a) 0.5 W
b) 5W
c) 0.2W
d) 2W

12) A 3-phase , 3-wire, ungrounded, 13.2-kv (phase-to-phase) wye-connected source is connected to a balanced
delta load that is grounded on Comer A. The voltage measured between comer band grond is most nearly
a) Half the phase-to-phase voltage
b) 7.62 kv
c) 13.2 kv
d) Cannot be determined
13) Which of the following regression models is not considered to be a linear regression model for
predicting Y in terms of X

14)

15) The CPU architecture shown below is best described as


a) Non-pipelined architecture
b) 1-stage pipeline architecture
c) 2-stage pipeline architecture
d) Harvard architecture
16) What would an initial investment of 1 million QR be after 5 years if the APR =9% accumulated monthly ? F
= P 1)
a) 1565681 QR
b) 1538624 QR
c) 1711867 QR
d) 1450000 QR
17) What is primary use of fast track scheduling?
a) To decrease the cost of construction
b) To decrease the cost of professional services
c) To avoid future cost increases
d) To guarantee project costs prior to the start of building

18) The final step in the definition of a work breakdown structure is to


a) Assign codes for each activity of the work package
b) Assign the cost account to a manager
c) Assign the work package to a manager
d) Develop the responsibility matrix
e) None of these are included in the final step
19) TQM stands for
a) Tool quality management
b) Test quality manager
c) Total quality manger
d) Total quality management
20) To make sure that an instrument did not driff with time, we need to
a) Heat it up
b) Change it
c) Calibrate it
d) Put it into a higher position
21) A large-scale integrated (LSI ) circuit is shown in the figure below. What is the best description of the circuit?

a) Phase detector
b) Phase-locked loop
c) Clock-phase skew compensator
d) Multiphase clock extractor

22) A 3-phase distribution line conductor congigurationis a s follows ← 3ft → • 4ft →•


a) 3.5
b) 4.0
c) 4.4
d) 5.0
23) We have three resistances each of 1 ohm. How many different values of resistance can be obtained
by different series-parallel combinations if all the three resistances are to remain in the circuit?
a) 3
b) 4
c) 5
d) 6
24) This is a type of semiconductor that only allows current ot flow in one direction . it is usually used to rectify
AC signals (conversion to DC)
a) Diode
b) Transformer
c) Inductor
25) The system shown is stable for

a) K > -2
b) -3 < k < 0
c) K< -2
d) -3 < k < 2
26) An opamp based non-inverting amplifier, the input impedance is
a) Zero
b) Infinity
c) Equal to the feedback resistance
d) Equal to the resistance connected
27) For the 4-wire RTD circuit shown, which of the following would cause the greatest measurement error in
VSENSE ?

a) Increase lead A resistance by 2


b) Increase lead B resistance by 3
c) Increase lead D resistance by 3
d) Current source has a 1% error
28) An ac voltmeter with a full-scale range of 5V is used to measure the output voltage of an amplifier. The
amplifier has an out put impedance of 2000 , and the meter has a sensitivity of 2000 /v. When connected
to the amplififer, the meter reads 2.5 V . if a different meter with a sensitivity of 100000 /V and a fll scale
meter of 5V is connected to the amplifier, the voltmeter reading (V) will be
a) 2.1
b) 3
c) 3.6
d) 5
1) In the figure
a) 6 W, 3 W and 9W are in series
b) 9 W and 6 W are in parallel and the combination is in series with 3 W
c) 3W , 6W and W are in parallel
d) 3W , 6W are in parallel and 9 W is in series
2) The CMOS inverter is superior to the R-pull up inverter due to its
a) High input impedence
b) Smaller propagation delay
c) Symmetric transfer characteristic
d) Symmetric transfer characteristics
3) A system witha n initial cost of 90000 dollars has an operating cost of 2.50 dollars per hour and is operated
16 hr/day for 300 days/year. After 10 years , the system has salvage value of 10000 dollars. Assuming the
interest rate is constant at 10% the total annalized cost over the 10-year life is most nearly

a) $12000
b) $14000
c) $20000
d) $26000
4) A certain communication channel has a signal-to-noise ratio of 7 and a bandwidth or 10 KHz. What is the
channel capacity?
a) 30 bps
b) 80 bps
c) 300 bps
d) 30000 bps
5) A circuit breaker is a
a) Current interrupted device
b) Power factor correcting device
c) Harmonics correcting device
d) All of the above
6) The resistance of a n electric bulb drawing 1.2 A current at 6.0 V is
a) 0.5 w
b) 5 w
c) 0.2 w
d) 2 w
7) The electric flux passing out through a closed surface is equal to
a) The line integral of the surface
b) Zero
c) The fluz density at the surface
d) The total change enclosed by the surface
e) The net surfaces integral of the current
8) An important step in the software lifecycle is testing . one type of testing is integration testing. Which of
the following is not true concerning integration test ?
a) Integration testing is employed to integrate separately tested pieces
b) In a top-down integration test , testing begins at the top levels to see whether the overall logical
design works and the interfaces between modules are correct
c) In a bottom-up integration test, testing begins first at the lowest-level sub-programs . a test driver is
used to set up the testing environment by declaring and assigning initial values to variables and then
calls the subprogram to be tested
d) In integration testing. Either a top-down or a bottom-up approach is selected to complete the test .
9) The onlyload on a 3-phase , 4-wire system is placed between phase B and Phase C . The phase-to-phase
voltage is 13.2 kv. The load is 500 kva at 0.85 lagigng power factor. The magnitude of the line current
(amperes) in phase C is most nearly
a) 65.6
b) 55.8
c) 37.9
d) 32.2
10) A SCADA system configuration reqires maximum values (i.e., the actual value of current when the transducer
is at full scale). The transducer ahs a fll-scale ac current of 5A. Sing a current transformer wit a trns raito of
400.5. the maximum current value (amperes) is most nearly
a) 1200
b) 800
c) 400
d) 300
11) Weak power systems means
a) Power system with high short circuit capability and low sensitivity to harmonics
b) Power system with high short circuit capability and high sensitivity to harmonics
c) Power system with low short circuit capability and low sensitivity to harmonics
d) Power system with low short circuit capability and high sensitivity to harmonics
12) An industrial plant is served by a 12470-v delta/480-v gronded-wye transformer. The high voltage side of the
transformer is served from a 12470-v wye-connected distribution line that has a grounded nerutral. The best
protection of the transformer against lightning strikes on the 12470-v line will result from surge arrester
connections of
a) Phase to ground on the 12470-v side of the transformer
b) Phase to phase on the 12470-v side of the transformer
c) Pahse to ground on the 480-v side of the transformer
d) Phase to neutral to ground on the 480-v side of the transformer
13) With respedt to relational record base data models at the user level a relationis represented in a

a) Key
b) List
c) Queue
d) Table
14) Of the following engineering disciplines which would be BEST suited to manage the construction of a natural
gas pipeline?

a) Petroleum engineer
b) Mechanical engineer
c) Civil engineer
d) Chemical engineer
15) In the circit shown , which resistor (s) is (are) redundant ?

a) R1 only
b) R1 and R3
16) The most important end state of project initiation is
a) Management assigns a project manager
b) Management provides the budget required
c) Management agrees to the details of works to be done
d) Management approves the project charter
e) None of the above
17) Following successor relationships are available for a project. What is the duration of the project?

18) When the receiver in previous question is turned to 540 kHz station, what other AM station offers
potential interference?

a) 85 kHz
b) 995 kHz
c) 1060 kHz
d) 1450 kHz
19) The main activity in project scope definition is to
a) Set up the meeting on project
b) Analyze the current budget plan
c) Meet with team members
d) Select team members
e) Define the work breakdown structure
20) Which of the following is no the transmission voltage in Qatar?

a) 66
b) 132
c) 220
d) 400
Elec 8

1) A motor is equipped with an optical shaft encoder to measure motor speed. The optical encoder provides
200 pulses per motor revolution. A microcontroller equipped with a real-time interrupt (RTI) capability is
used to measure motor speed. The RTI interval is 32.768 ms. The microcontroller counts 372 pulses from
the optical encoder in the RTI interval. The speed (rpm) of the motor is :
a) 33
b) 568
c) 3276
d) 3400
2) Of the following engineering disciplines, who would be BEST suited to design and operate an
automobile factory
a) Petroleum engineer
b) Mechanical engineer
c) Civil engineer
d) Chemical engineer
3) Which type of special-purpose diode is formed by a junction between a layer of metal and a layer of
semiconductor
a) A schottky diode
b) A tunnel diode
c) A zener diode
d) A varactor diode
4) The voltage waveform generated by an alternator having 4 poles and rotating at 750 rpm will have a
frequency of
a) 60 Hz
b) 50 Hz
c) 25 Hz
d) None of the above
5) The critical path in a project network is the
a) Shortest path through the network
b) Longest path through the network
c) Network path with the most difficult activities
d) Network path using the most resources
e) Network path with the most merge activities
f) None of the above

6) Sustainable development involves


a) Reducing consumption, increasing efficiency and using renewable energies
b) Larger buildings using stronger design and a materials
c) Developing better transportation by building more roads
d) Using all resources at maximum rates
e) Searching for more deposits of fossil fuels
7) When using the method of symmetrical components , which of the following statements is most
nearly correct
a) The three zero-sequence current phasors are equal in magnitude and displaced by 1200
b) The three positive=sequence and the three negative-sequence current phases are all equal in
magnitude , but have opposite phase
c) In a wye-connected synchronous Generator, the voltage drop through the neutral grounding resistor, R
is equal to √3 IO R, where IO is the zero sequence current.
d) Positive-Sequence and negative-sequence currents cannot pass through the neutral grounding resistor
in a wye-connected generator.
8) The device used for measuring potential difference is known a s
a) Potentiometer
b) Ammeter
c) Galvanometer
d) Voltmeter
9) Intersymbol interface is eliminated by applying which of the following ?
a) Nyquist criterion
b) Pulse code modulation
c) Shannon bandwidth
d) SSB modulation
10) A synchronous motor working on leading power factor but not driving any mechanical load, is known as
a) Universal motor
b) Reluctance motor
c) Synchronous condenser
d) Noneof the above
11) An over-excited alternator is operating at
a) Lagging power factor
b) Unity power factor
c) Leading power factor
d) None of the above
12) An over-excited alternator is operating at
a) Lagging power factor
b) Unity power factor
c) Leading power factor
d) None of the above
13) A 3-phase capacitor rated at 240 V and 110 kvar has been proposed for correcting the power factor of a 3-
phase induction motor operating at 280 v . the reactive power (kvar) that will be provided by the capacitor
is most nearly
a) 82.6
b) 95.3
c) 110
d) 127
14) A room with a floor area of 50ft × 30ft and a ceiling height of 10 ft has luminaires suspended 2ft from the
ceiling assuming a working plane of 30 in. And a required illumination level of 50 fc, the net luminous
flux (lumens) using fixtures with a coefficient of utilization of 0.78 is most nearly.
a) 48000
b) 58000
c) 75000
d) 96000
15) The room amplifier in a wireless system amplifies
a) The baseband signal
b) The modulated signal only
c) The encoded and modulated signal
d) The recieved signal
16) Which of the following regression models is not considered to be a linear regression model for predicting Y
in terms of X?
17) The activity on node network shown below describes a project consisting of 8 tasks A-H. Each node
indicates duration in weeks relationship are finish-to-start. The minimum time to complete the project is

a) 15 weeks
b) 16 weeks
c) 17 weeks
d) 18 weeks
18) A basic time-domain reflectometry (TDR) system is used with an oscilloscope to display the waveform at
the input end of a line driven by an alternating 0-1 square waveform signal in a non-return-to-zero (NRZ)
digital system.
A 1000-m cable is terminated witha short circit at the far end. The first reflected wave appears 9.43 µs after
the incident waveform. The actual velocity in the cable divided by the speed of light is Vp = 2L/TO
a) 0.35
b) 0.71
c) 1.0
d) 1.41
19) Which of the following choices is not one of the stages of a project life cycle?
a) Concept
b) Initiation
c) Planning
d) Execution
e) Delivery/closure
20) The power factor of an alternator depends on
a) Speed of the rotor
b) Core losses in the machine
c) Load connected to the machine
d) Armature losses in the machine
21) For the design and implementation of smoke detectors and doors control system, it is preferable that we
use
a) FPGAs
b) Microcontrollers
c) ASIC
22) What is the most important components of sustainability?
a) Economical
b) Social
c) Environmental
d) All are equally important
23) What is the maximum allowable size of the over-current device normally allowed to protect an AWG # 12
THHW conductor rated for 90°c used in an ambient temperature of 55°C? Only standard size over –current
devices are available
a) 10
b) 15
c) 20
d) 30
24) The only load on a 3-phase , 4-wire system is placed between phase B and phase C . the phase to phase-to-
phase voltage is 13.2 kv. The load is 500 KVA at 0.85 lagging power factor. The magnitude of the line current
(amperes) in phase C is most nearly
a) 65.6
b) 55.8
c) 37.9
d) 32.2
25) An engineer chooses open collector output TTL technology to provide sufficient current to drive a device .
the circuit shown is implemented with a 7405 package and corresponds to the following logic function
(assume that a logic 0 corresponds to)

a) AND
b) NAND
c) OR
d) NOR
26) If the signal is power doubled a t a given transmitter, what is the decibel increase?
a) 0.5 dB
b) 2 dB
c) 3 dB
d) 4 dB
ELEC 9

1) Which of the following junction diodes are forward biased?


a) Anode = + 7v, cathode= +10v
b) Anode = +5v, cathode = +3v
c) Anode = +0.3v, cathode = +5v
2) What is the maximum allowable size of the over-current device normally allowed to protect an AWG #12
THHW condu temperature of 550 C? Only standard size over current devices are available
a) 10 A
b) 15 A
c) 20 A
d) 30 A
3) A differential relay, designed to protect a zone of the distribution system, uses current transformer (CTS)
connected to annually CTS . The axilary CTS must match both the phase shift and the ratio of the
differential relay CTS if the values do not match. Which of the following is the least likely outcome
a) The trip could occur at a lower level than expected
b) The trip could occur at higher level than expected
c) The trip could occur under a non-fault conditions
d) The trip could occur only when the CTs are wired in parallel
4) A single phase transformer rated 100/7.2 kv has an impedance of 10.0%. during a factory short circuit
test done at rated current the voltage the HV terminals will be most nearly
a) 0.72
b) 7.2
c) 10
d) 100
5) We have three resistances each of 1 ohm. How many different values of resistance can be obtained
by different series-parallel combinations if at all the three resistances are to remain in the circuit?
a) 3
b) 4
c) 5
d) 6
6) Weak power systems means
a) Power system with high short circuit capability and low sensitivity to harmonics
b) Power system with high short circuit capability and high sensitivity to harmonics
c) Power system with low short circuit capability and low sensitivity to harmonics
d) Power system with low short circuit capability and high sensitivity to harmonics

7) The circuit shown is a ground-fault protection scheme


The purpose of R is to
a) Limit the ground current and prevent damage only
b) Maintain a potential difference between N and EG only
c) Decrease the interrupting rating required of M only
d) a,b,c are correct
8) the output is to be maintained at 24 V , while the input varies from 120 V to 126 V with a load current
ranging from 0A to 5 A . assume ideal conditions that is the keep alive current is zero and the zener
resistance, RZ is negligible

Useful relationships : Rs = (Vin,min - VZM) / IL,max PD =IZ,MAX . VZM PRS = I² Z,MAX . RS


What is the minimum diode power rating that Can be used?
a) 100
b) 150
c) 500
d) 600
9) the self discharge rate of a lead-acid battery is least dependent on which of the following factors?
a) concentration (specific gravity) of electrolyte
b) age of battery
c) temperature
d) nominal voltage of battery
10) the highest element in the hierarchical breakdown of the WBS IS
a) a work package
b) subdeliverables
c) a cost account
d) major deliverables
e) the project
11) find the early and late start of activity D for the project

a) ES = 12, LS = 15
b) ES = 13, LS = 22
C) ES = 19, LS = 24

12) IN WHICH OF FIGURE THE RELATIONSHIP BETWEEN VOLTAGE V AND CURRENT IS IN ACCORDANCE
WITH OHMS LAW?

a) figure A
b) figure B
c) figure C
d) figure D

13) The transfer function YI R for the block diagram shown below is
14) steel is preferred as reinforcing material in concrete
because a) it is easily available
b) it is the cheapest and good in strength
c) the coefficient of thermal expansion of steel and concrete are almost the
same d) it forms a good bond

14) which of the following would not be classified as an opportunity to do a


project? a) increasing product demand
b) lot of employees
c) emerging markets
d) favourable international exchange rates
e) none of these are organizational opportunities

15) a power plant uses a turbine-driven synchronous generator rated 3-phase. 150 MVA, 13.8 KV,
0.85 lagging power factor. All rated conditions the power output (MW) is most nearly
a) 60
b)75
c)125
d)128

16) the power factor of an alternator depends on


a) speed of the rotor
b) core losses in the machine
c) load connected to the machine
d) armature losses in the machine

17) the main cause for transformer humming


is a) vibrations in the insulating and cooling oil
b) vibrations in the core laminations
c) vibrations in the bushes
d) none of the above

18) consider the three-stages r-f amplifier shown below ARI refers to the input amplifier stage. AR2
to the second stage, AR2 to the second stage and AR3 to the output stage
For this amplifier configuration the total noise figure (DB) is most nearly

a) 6.6
b) 8.6
c) 10.5
d) 12.3

19) the power factor is defined as

a) sine of the angle between the voltage and current

b) cosine of the angle between the voltage and current

c) tangent of the angle between the voltage and current

d) cotangent of the angle between the voltage and current

20) the selected collector supply voltage is 12 V . the transistor must be on for pulses of 150 µA or greater only ,
what is the required value of the load resistance?

a) 200

b) 300

c) 400

d) 600

21) a lossy transmission line is used to connect a transmitter to an antenna. If the VSWR measured at the
antenna end of the transmission line is 1.5 which of the following statements is correct?

a) the VSWR measured at the transmitter end of the transmission line is smaller than 1.5

b) the VSWR measured at the transmitter end of the transmission line is larger than 1.5

c) the VSWR measured at the transmitter end of the transmission line is equal to 1.5
d) the characteristic impedance of the antenna matches exactly the characteristic impedance os the transmissionline

22) which of the following is least bothered as a constant to the project?

a) time

b) people

c) cost

d) performance

e) both b and d are not typical constants

23) the immediate...................................must be completed before the next activity can start in the project

network a) critical activities

b) burst activities

c) predecessor activities

d) successor activities e)

none of the above f) all

of the above

25) an overcurrent relay is used ot protect a circuit with a maximum 3-phase fault current of 8000 A primary A 400:5
current transformer ratio and a 5-A relay tap setting are selected. If the total secondary burden on the current
transformer for the maximum fault condition is 1:10 , the excitation voltage (V) that must be developed by the
current transformer is most nearly

a) 100

b) 110

c) 115

d) 120

26) the only load on a 3-phase , 4-wire system is placed between phase B and Phase C . the phase –to- phase voltage
is 13.2 kv. The load is 500 KVA at 0.85 lagging power factor . the magnitude of the line current (amperes ) in phase C
is most nearly

a) 65.6

b) 55.8

c) 37.9
d) 32.2

27) for which of the following circuit elements is superposition valid?

a) independent source

b) dependent source c)
charged capacitor d)

inductor with Iintial ≠ 0


1. In transformer saturation

Select one:

2. For the 4-wire RTD Circuit shown, which of the following would case the greatest
measurement error in VSense ?

Select one:

3. Incandescent lamps operate normally at a power factor of:

Select one:
4. The final step in the definition of a Work Breakdown Structure is to :

Select one:

5. Permanent magnet has a relative permeability that is ____________ magnetic material

Select one:

6. Open circuit test on a transformer is conducted to obtain:

Select one:

7. If the collector suppl l age i 12 V a d he e i i 400 , ha i he c di i f he


transistor at time t2?

Select one:
8. Figure 1 represents equivalent transformations of the components in Figure 2. The values of
the transformed source and resistor in figure 1 are most nearly:

Select one:
9. An antenna has an effective aperture of 10m2. What additional information is required to
determine the amplifier power?

Select one:

10. Which of the estimates listed would occur last in project time line?

Select one:

11. All of the followings are true about work Packages except:

Select one:

12. Scheduling periodic tasks to execute on a processor based on assigning the highest priority to
task that has the shortest period greatest frequency is known as;
Select one:

13. It is proposed that two 3 phase transformers be connected in parallel to serve a large load.
Transformer 1 is wye-delta, and Transformer 2 is wye-wye. Which of the following statements is
most correct?

Select One;

14. All of the following are properties of fuses rather than circuit breakers, with o e exception ,
which item is the property of circuit breakers?

Select one:
15. For effective earthling, which of the flowing mixture is preferred for filling around the earth
electrode?

Select one:

16. The initial investment for a project is 2.0 million QR. A net annual profit of 150,000 QR is
anticipated. Using a 10% desired rate of return on the investment that is the payback period for
the project?

Select one:
17. The resistance of an electric bulb drawing 1.2 A current at 6.0 V is___________

Select one:

18. In the circuit below, Switch S 1 closes at t= O. The diode D is rated at a maximum peak
current of 5 A. Assume that the initial charge on the capacitor is zero. The minimum value of R
(n) to prevent exceeding the diode maximum peak current is most nearly.

Select one:
19. 100 resistors of 100 ohms each arc connected in parallel. Their equivalent resistances will be:

Select one:

20. A-phase , 3-wire, ungrounded, 13.2-Kv (phase-to-phase) wye-connected source is connected


to a balanced delta load that is grounded on corner A. The voltage measured between Comer
Band ground is most nearly.

Select One:

21. Construction work should begin:

Select one:

22. A single-phase transformer rated 100/7.2 kV has an impedance of 10.0%. During a factory
short circuit test done at rated current, the voltage kv applied to the HV terminals will be most
nearly:
Select one:

23.An engineer chooses open collector output TTL Technology to provide sufficient current to a
drive a device. The circuit shows is implemented with a 7405 package and corresponds to the
following logic function (assume that a logic-0 corresponds to 0 V):

Select one:

24. A a a c 90,000 a a a c 2.50/ a d a d 16


/da 300 da / a . A 10 a , a a a a a 10,000 , Assuming
the interest rate is constant at 10%, the total annualized cost over the 10-year life is most nearly:
Select one:

25. The primary difference between a programmable logic array designated 16R8 and one
designated 20 R8 is that the 20R8 has.

Select one:

26. The CPO architecture shown in the figure below is best described as:

Select one:
27. In 50Hz induction machine, if the no load speed is 2900rpm, the slip frequency is:

Select one:
1. The third harmonic of the Fourier series for the waveform in the figure has a
frequency (Hz) of:

Select one:

2. The unit of conductance is:

Select one:

3. Project control is a function that takes place:

Select one:

4. An over-excited alternator is operating at:

Select one:
5. A series of fuel cells is connected to produce a no-load voltage of 230 V at a rated
voltage of 300 V the cells provide 2.0 MW to a DC-AC converter. Assuming the cell
van be modeled as a standard battery, what is the total internal resistance of the fuel
cells? Hint: ,

Select one:

6. The forward pass in project network calculations determines the :

Select one:

7. The Accreditation Board for Engineering and Technology (ABET) is an accrediting


agency for:

Select one:

8. What is the common or usual method to ensure that the final set of construction
documents satisfy the clients program and design goals?

Select one:
9. For which of the following can 10base T not be used without additional hardware
conversation?

Select one:

10. Consider the oscillator circuit shown below. This circuit uses which resonant mode(s)
of the crystal X1?

Select one:
11. The output is to be maintained at 24 V, while the input varies from 120 V to 126 V
with a load current ranging from 0 A to 5A. Assume ideal conditions, that is, keep
alive current is zero and the Zener resistance, Rz, is negligible.

What is the required supply resistance to ensure proper operation of the zener

Select one:

12. Which type of braking is used in an induction motor:

Select one:
1. Heat produced in a current carrying wire in 5s is 60 J. The same current is passed
through another wire of half the resistance. The heat produced in 5s will be
_________

Select one:

2. The resistance of an electric bulb drawing 1.2 A current at 6.0 V is ___________

Select one:

3. An engineer is offered some additional gifts and services in exchange for using
superior materials on a remodeling project. This was not detailed in the contract . He
should:

Select one:

4. In transformer saturation:

Select one:

5. An ACSR conductor having 7 steel stands surrounded by 25 aluminum conductor will


be specified as:

Select one:
6. Of the following engineering disciplines, who would be BEST suited to design and
operate an automobile factory?

Select one:

7. Among the sites being considered for a new main library are those adjacent to the
following areas or services. The most appropriate site is one that is adjacent to:

Select one:

8. The travelling cranes are mostly driven by:

Select one:

9. A circuit breaker is a:

Select one:

10. A project manager is supervising construction of a medium-sized part assembly


workshop. He submits a report to his boss indicating the cost breakdown of the
foundation and framing work based on the soil analysis and loading specifications for
the building. The total came to $25,000. His boss then told him to do whatever it takes
to get that figure down to $20,000. He should:

Select one:

11. A wristwatch mercury cell has a capacity of 200 × 10-3 A H. How many months can
the watch function without replacement if it draws 15 × 10-6 A? Hint (Dh=lt)

Select one:

12. The bode plot for the circuit shown for

Select one:
13. The selected collector supply voltage is 12 V. The transistor must be on for pulses of

150 greater only. What is required value of the load resistance?

Select one:

14. The most important end state of project initiation is:

Select one:

15. We have three resistances each of 1 ohm. How many different values of resistance
can be obtained by different series-parallel combinations if all the three resistances are
to remain in the circuit?

Select one:
16. The OP-AMP circuit performs the function of:

Select one:

17. For effective earthing, which of the following mixture is preferred for around the
earth electrode?

Select one:

18. A system with an initial cost of $90,000 has an operating cost of $2.50/hr and is
operated 16 hr/day for 300 days/year. After 10 years, the system has a salvage value
of $10,000. Assuming the interest rate is constant at 10%, the total annualized cost
over the 10-year life is most nearly:

Select one:
19. You received an invoice from your computers supplier for me full amount of the
purchase order in looking at the purchase order terms, you find that if says” Seller to
provide twenty (25) computers”. However, you have received only (20) computers.
What should you do?

Select one:

20. An underground system is built for a military marine system with a normal voltage
level, A. Following fault analysis design, the insulation of the distribution system is
selected, What is most nearly the voltage level for which the insulation on the
distribution system is designed? (1/ √2A

Select one:

21. A BJT is used to ampility in:

Select one:

22. This question investigates the performance of the temperature measurement circuit
shown below. The temperature sensor is linear, with the following open-circuit
voltages:

The operational amplifier (op amp) is ideal.

At 100° C, the maximum output voltage at due to the tolerance in R2 is most


nearly:
Select one:

23. The power factor is defined a:

Select one:

24. The source voltage in the circuit shown is v= 100sin 377t, the peak reverse voltage
applied to the diode would be:

Select one:
25. The spinning reserve is the :

Select one:

26. To make sure that an instrument did not drift with time, we need to

Select one:

27. A certain communication signal uses a bandwidth, BW, of 2 kHz. What is the
classification of this signal?

Select one:
1. The term sustainability refers to:

A. Maintaining resource use at current or higher levels.


B. Keeping the natural environment and human society in a happy, healthy and functional
state.
C. Holding or increasing the current quality of human life.
D. Always focusing on fulfilling shortage term needs.
E. Opposing change from current policies.

2. Which circuit breaker in commonly used in the distribution level?

A. Air break circuit breaker


B. Air blast circuit breaker
C. SF6 circuit breaker
D. Tank type oil circuit breaker

3. We have three resistances of values 2 , 3 and 6 . Which of the following combination will give
an effective resistance of 4

A. All the three resistance in parallel


B. 2 resis ance in series i h parallel combina ion of and resis ance
C. 3 resistance in series with parallel combination of 2 and resis ance
D. 6 resis ance in series i h parallel combina ion of and resis ance

4. The voltage gain of an amplifier with 9% negative feedback is 10. The voltage gain without
feedback will be

A. 10
B. 1.25
C. 100
D. 90

5. Which of the following best describes the sequential steps in an Object-Oriented design?

A. Define classes, define interface techniques , define collaboration diagrams, define design
diagrams
B. Define use case, define programming language, define interface techniques, define class
C. Define programming language, define class models, define design class diagrams, define
collaboration diagram
D. Define use case, define conceptual model, define collaboration diagrams, define design class
diagrams
6. What is the least instructive solution to connection hijacking?

A. Use of one time password


B. Physical security of the communication link
C. High security login procedures
D. Full scale encryption

7. In 50Hz induction machine, if the no load speed is 2900 rpm, the slip frequency is

A. 0.00 Hz
B. 0.67 Hz
C. 1.33 Hz
D. 1.67 Hz

8. In Harvard architecture

A. Code and data spaces are merged


B. Code and data spaces separated
C. Code space is contained in ROM and data space is contained in RAM
D. Code space is contained RAM and data space is contained in ROM

9. A system with an initial cost of $90,000 has an operating cost of $2.50/hr and is operated 16
hr/day for 300 days/year. After 10 years, the system has a salvage value of $10,000. Assuming the
interest rate is constant at 10%, the total annualized cost over the 10-Yearlife is most nearly

A. $ 12,000
B. $ 14,000
C. $ 20,000
D. $ 26,000

10. A transistor amplifier circuit operated with an emitter current of 2 mA. The collector current is
1.98mA. The common emitter current gain ( dc) of the transistor used in the circuit is

A. 45
B. 50
C. 100
D. 125
E. 200
11. The immediate _______________ must be completed before the next activity can start in the
project network

A. Critical activities
B. Bust activities
C. Predecessor activities
D. Successor activities
E. None of the above
F. All the above

12. During which of the following categories are you more likely to find status reports many changes
and the creation of forecasts?

A. Concept
B. Initiation
C. Planning
D. Execution
E. Closure

13. Activity on arrow needs to use dummy activities to avoid precedence problem that can happen
due to:

A. Parallel activities
B. Critical path activities
C. Burst activities
D. Merge activities
E. Independent activities
F. None of the above

14. The unit of conductance is

A. Per ohm
B. Ohm/m
C. Mho/m
D. Mho

15. Software maintenance activities can be classified in to several maintenance types. Which of the
following is not a software maintenance type?

A. Adaptive maintenance
B. Corrective maintenance
C. Customer- initiated maintenance
D. Perfective maintenance

16. The spinning reserve is the

A. Generating capacity that is connected to the grid and ready to take the load
B. Generating capacity that is available for service but not in operation
C. Generating capacity under maintenance
D. None of the above

17. Activity on arrow diagram is shown below. Find the duration of the project

A. 32 Days
B. 25 Days
C. 27 Days
D. 35 Days

18. The most important factor to be considered in distribution system is

A. Efficiency
B. Power factor
C. Voltage regulation
D. Reliability

19. Hysteresis losses appears

A. In nonmagnetic material using AC Supply


B. In magnetic material using AC Supply
C. In non-magnetic material using DC supply
D. In magnetic material using DC Supply

20. Increasing the current withdrawn from a battery has what effect on the battery capacity and
why?
A. Increased capacity , Which is caused by less internal heat loss
B. Increased capacity , which is caused by lower internal resistance
C. Decreased capacity, which is caused by higher load voltage drop
D. Decreased capacity, which is caused by increased polarization

21. The OP-AMP circuit shown performs the function of

A. Amplification
B. Integration
C. Summing
D. Attenuation

22. What does QSAS stands for?

A. Qatar standards of architectural sustainability


B. Qatar sustainability assessment system
C. Qatar system for assessing sustainability
D. Qatar sustainability assessment standards

23. In general, when comparing the BJT and MOSFET transistors, three main differences

A. The device that depends more on geometry (Width, Length, etc.,) is BJT
B. The device is capable of higher amplification is MOSFET
C. The device that dissipates no power at the input (zero input current) is MOSFET

24. In transformer saturation

A. The efficiency decreases and the no-load current increases


B. The efficiency decreases and the no-load current decreases
C. The efficiency increase and the no-load current increases
D. The efficiency increase and the no-load current decrease
25. The single phase motor generally used with house hold ceiling fans is

A. Split phase type


B. Capacitor start type
C. Permanent capacitor type
D. None of the above

26. The only load on a 3-phase, 4-wire system is placed between phase B and Phase C. The phase to
phase voltage is 13.2 Kv. The load is 500KVA at 0.85 lagging power factor. The magnitude of the line
current (amperes) in phase C is most nearly

A. 65.6
B. 55.8
C. 37.9
D. 32.2

27. Which of the following statements is incorrect?

A. Doping pure semiconductor material with small amounts of donor impurities produces an n-
type semiconductor.
B. Conduction within pure semiconductors is termed intrinsic conduction
C. At room temperatures, pure semiconductors make excellent conductors
D. The dominant charge carriers with in doped semiconductors are called majority charge
carriers.
1. Project management is ideally suited for a business environment requiring all of the except
a) Accountability
b) Flexibility
c) Innovation
d) Speed
e) Repeatability

2. The lowest element in the hierarchical breakdown of the WBS is


a) Deliverable
b) A work package
c) A cost account
d) A lowest sub deliverable
e) An object
f) None of the above

3. Tests at two terminals of a linear network produce the following


- With the terminals shorted th current in the short circuit is 3.0A
- With a conductance of 0.2 S connected to the terminals the voltage between the
terminals is 5 V
The linear network may be replaced by current source amperes in parallel with a
conductance (S) of most
a) Current 1.0 conductance 0.2
b) 3.0 0.4
c) 2.0 0.6
d) 3.0 0.6

4. 100 resistors of 100 ohms each arc connected in parallel. Their equivalent resistances will be
a) 10000 ohms
b) 100 ohms
c) 1 ohms
d) 1/10000 ohm

5. The one line diagram below represents three single phase transformers connected in a
delta-wye arrangement and rated for the line to line voltages indicated. The turns ratio of

individual single phase transformers is most nearly


a) 2.8
b) 4.8
c) 8.3
d) 14.4

6. The equipment grounding conductor for an electrical distribution system within a building is
the conductor that connects noncurrent carrying parts of the equipment and raceways to
ground at the service equipment or the source of a separately derived system. The purpose
of an equipment grounding conductor is to provide a
a) Low impedance to ground to limit voltage to ground on exposed conducting surfaces
and help ensure ground fault clearing
b) Path to ground for all harmonic s
c) Path to ground for triplen harmonics
d) Low impedance to ground to limit voltage to ground on exposed conducting surfaces
help ensureground fault clearing and provide a path to ground for triplen harmonics.

7. An important step in the software lifecycle is testing. One type of testing is integration
testing. Which of the following is not true concerning integration testing.
a) Integration testing is employed to integrate separately tested pieces
b) In a top down integration test. Testing begins at the top levels to see whether the overall
logical design works and the interfaces between modules are correct
c) Ina bottom up integration test testing begins first at the lowest level subprograms. A test
driver is used to set up the testing environment by declaring and assigning initial values
to variables and then calls the subprogram to be tested
d) In integration testing either a top down or a bottom up approach is selected to complete
the test

8. A copper cable used in a plain old telephone service line has a loss of 1.5 Dv/Km. What is the
approximate the central office?
a) 1.5 dB
b) 15 Db
c) 20 Db
d) 220 db

9. Which of the following characteristics is not typical of a project manager?


a) Managing a temporary activity
b) Possesses in depth technical knowledge
c) Managing a non repetitive activity
d) Manages independent;y of the formal organization

10. The spinning reserve is the


a) Generating capacity that is connected to the grid and ready to take the load
b) Generating capacity that is available for service but not in operation
c) Generating capacity under maintenance
d) None of the above

11. For last switching of an NMOS R-pull UP inverter (W/L)should be


a) Large
b) Small
c) Equal to the drain current
d) Equal to the power dissipated during switching
12. Weak power systems means
a) Power system with high short circuit capability and low sensitivity to harmonics
b) Power system with high short circuit capability and high sensitivity to harmonics
c) Power system with low short circuit capability and low sensitivity to harmonics
d) Power system with low short circuit capability and low sensitivity to harmonics

13. A cyclic redundancy check (CRC) generator is based on what operation?


a) Exclusive OR
b) MODULO-2-division
c) Bit wise add with carry
d) Twos complement addition

14. Consider the three stage r-t amplifier shown below. ARI refers to the input amplifier stage.
AR2 to the second stage and AR3 to the output stage

a) 6.6
b) 8.6
c) 8.3
d) 12.3

15. A differential amplifier with high CMRRS means


a) High rejection of noise
b) Amplify noise
c) High amplification gain

16. What is meant by ethics?


a) Codes of behaviour and courtesy
b) General and abstract concepts of right and wrong behaviour culled from philosophy ,
theology, professional societies
c) A system of rules established by authority, society or custom where violations carry
penalties
d) Accepted standards of right and wrong applied to personal begavior driven by religious
and or family and environment background

17. An engineer chooses open-collector output TTL technology to provide sufficient current to
drive a device. The circuit shown is implemented with a 7405 package and corresponds to
the following logic function (assume that a logic-0 corresponds to 0 V)
a) AND
b) NAND
c) OR
d) NOR

18. Which of the following junction diodes are forward biased?


a) Anode = +7V, Cathode = +10V
b) Anode = +5V, Cathode = +3V
c) Anode = +0.3V, Cathode = +5V

19. In a cascade amplifier to reduce the loading effect at the input impedance of the first stage
should be
a) Very high
b) Intermediate
c) Very small

20. An over current relay is used to protect a circuit with a maximum 3-phase fault current of
8000 a primary . A 400:5 current transformer ratio and a 5-A relay tap setting are selected. If
the total secondary burden on the current transformer for the maximum fault condition is
1.10 ohms, the excitation voltage (V) that must be developed by a current transformer is
most nearly
a) 100
b) 110
c) 115
d) 120

21. Power factor correction devices used for


a) Mitigating the power factor
b) Increasing the power factor
c) Getting the power factor at unity
d) None of the above

22. A de current of 50A is flowing in a isolated wire. The magnitude of the magnetic field
intensity, H (A/m), 10 cm from the center of the wire is : H=1/2𝜋
a) 0.05
b) 8
c) 43
d) 80

23. When a n activity network is developed by using forward and backward pass we can find out
a) The longest time period that the project will take
b) The number of total slacks that project managers might have
c) The number of free slacks in the network
d) The earliest and latest time that an activity can finish
e) Only A and B are correct
f) Only A,B and C are correct
g) A, B , C nad D are all correct

24. The resistance across AB is

a) 4
b) 1
c) 2
d) 0.5

25. A certain communication channel has a signal to noise ratio of 7 and a bandwidth of 10 kHz.
What is the channel capacity?
a) 30 bps
b) 80 bps
c) 3000 bps
d) 30000 bps

26. A real time kernel is considered a bare bones real-time operating system. At a minimum a
kernel should provide
a) Task management , file management, memory management
b) Task scheduling, task dispatching, file management
c) Intertask communication, task dispatching, memory allocation
d) Task scheduling , task dispatching, intertask communication

27. A microwave cellular telephone system is built with antenna towers 90m height what is the
most nearly the maximum distance between two towers?
a) 20 km
b) 30 km
c) 40 km
d) 50
electrical10

1) Two resistances R1 and R2 give combined resistance of 4.5ohms when in series and 1ohm when in
parallel. The resistances are

a)3 ohms and 6 ohms

b)3 ohms and 9 ohms

c)1.5 ohms and 3 ohms

d)1.5 ohms and 0.5 ohms

2) An underground system is built for a military marine system with a normal voltage level. A following
fault analys is design the insulation is most nearly the voltage level for which the insulation on the
distribution system is designed?

a A

b A

c A

d)D)2A

3) A variable resistance R is connected across a source of voltage V if the value of the resistance R is
gradually varied the relationship between I and R will be represented by which curve?

a) Figure A

b) Figure B

c) Figure C

d) Figure D

4) For the circuit shown the phase shit of the transfer function V°/VIat very high frequencies is:
a) 90°
b) 0°
c) -90°
d) -180°

5) A radio station transmits 50KW with a directivity gain of 105. What is the power density 10km
from the radiating antenna?

a) 0.060mW/m²

b) 5.9mW/m²

c) 33mW/m²

d) 75mW/m²

6) The voltage gain of an amplifier with 9% negative feedback is 10. The voltage gain without
feedback will be

a) 10

b) 1.25

c) 100

d) 90

7) Inter symbol interferenceis eliminated by applying which of the following

a) Nyquistcriterion

b) Pulsecodemodulation

c) Shannonbandwidth

d) SSB modulation

8) A lossy transmission line is used to connect a transmitter to an antenna. If the VSWR measured at
the antenna end of the transmission line is1.5, which of the following statements is correct?
a) The VSWR measured at the transmitter end of the transmission line is smaller than1.5

b) The VSWR measured at the transmitter end of the transmission line is larger than 1.5

c) The VSWR measured at the transmitter end of the transmission line is equal to 1.5

e) The characteristic impedance of the antenna matches exactly the characteristic impedance
of the transmission line

9) Al the following are the properties of fuses rather than circuit breakers, with one exception.
Which item is the property of circuit breakers?

a) Adjustable time-current characteristics

b) Low initial costs

c) Longer down time over operation

d) Simplify

10) In 50Hz induction machine, if the no load speed is 745r.p.m the synchronous speed is

a) 700rpm

b) 750rpm

c) 800rpm

d) 850rpm

11) The SCADA system configuration uses input from an instrument CT with ratio of 100:5. The
transducer supplying the SCADA has a full – scale AC current value of 2.5A. What is most nearly
the maximum current in the primary side of the CT? Hint:[(lp/ls)=(hs/hp)]

a) 40A

b) 50A

c) 65A

d) 70A

12) Which of the special – purpose diode is for medbya junction between a layer of metalanda layer
of semiconductor?

a) A schootlky diode

b) A atunnel diode

C ) A Zener diode
c) A varacor diode

13) The traveling cranes are mostly driven by

a) Wardleonard controled DC shunt m motor

b) AC slip ring motor

c) Synchronous motor

d) DC differentially compound motor

14) If the transformer operated insaturation

a) The no load current is low

b) The no load current is high

c) The no load current is not affected

d) The no load current is cancelled

15) Which of the following statements best describes how a power transformers total losses vary with
kVA load?

a) Losses are linearly proportional to load

b) Losses are proportional to the square root of the load

c) Losses are proportional to the square of the load

d) Losses are proportional to the square of the load plus a constant

16) The forward pass in project network calculations determines the

a) Earliest times an activity can begin

b) Earliest times an activity can be finished

c) The longest time that project can take

d) Critical path of the project

e) Only A and B are correct

f) F, A, B and C are all correct

17) The direction of the forecasting on a moving charge placed in a magnetic field is

a) Perpendicular to the magnetic field

b) Opposite to the direction of motion of the charge


c) A long the direction of the magnetic field

d) Along the direction of motion of the charge

e) Atanoblique angle to the magnetic field

18) According to brundtland report (WCED, 1987) defining the mainat tributes of<sustainability and
sustainable development, what are the three main pillars of sustainable development?

a) Economic social and cultural factors

b) Economic cultural and environmental factors

c) Economic environmental and social factors

d) Political social and environmental factors

19) Open circuit test on a transformer is conducted to obtain


a) Ohmic loss only
b) Hysteresis loss only
c) Eddy current loss only
d) Core loss only

19) While working on the final stages of a job you notice that one small clause in the contract has
been violated accidentally

a) Tell the client about the discrepancy and ask him or her or them what to do

b) Look for a loophole in the contract that would enable you to avoid redoing the work

c) Don worry about it; let your boss or the client worry about it later. if i important they
will address the subject

d) Fire the person who caused the contract violation

20) Digital telecommunication equipment provides connection oriented AND/OR connectionless


service. Connection oriented service is provided by

a) ATM

b) ETHERNET

c) FDDI

d) SMDS

21) A motor is equipped with an optical shaft encoder to measreotor speed. The optical encoder provides
200 pulses per motor revolution. A microcontroller equipped with a real-time interrupt (RTI)
capability is used to measure motor speed. The RTI intervals 32768 MS.THE MICROCONTROLLER
counts 372 plses from the optical encoder in the RTI interval. The speed (rpm) of the motor is:
a) 33

b) 568

c) 3276

d) 3400

22) The immediate must be completed before the next activity can start in the project network

a) Critical activities

b) Burst activities

c) Predecessor activities

d) Successor activities

e) None of the above

f) All of the above

23) The power factor is defines as

a) Sine of the angle between the voltage and current

b) Cosine of the angle between the voltage and current

c) Tangent of the angle between the voltage and current

d) Co-tangent of the angle between the voltage and current

24) A transmitter operating at 23.6GHz has a power output of20Nw. A receiver is located 8miles from
the transmitter (dB) is

Hint: free space loss = 20log [4πd c f

a) 142

b) 124

c) 119

d) 115

You might also like