Professional Documents
Culture Documents
MM3575 Series: 3 To 5cells Li-ion/Li-polymer Battery Protection IC
MM3575 Series: 3 To 5cells Li-ion/Li-polymer Battery Protection IC
Outline
The MM3575 series are protection IC using high voltage CMOS process for overcharge, overdischarge
and overcurrent protection of the rechargeable Lithium-ion or Lithium-polymer battery. The overcharge,
overdischarge, discharging overcurrent, charging overcurrent, cell balance and V5 to V3 pin disconnect
of the rechargeable 3 to 5cell Lithium-ion or Lithium-polymer battery can be detected. By using cascade
connection, it is also possible to protect 6 or more cells rechargeable Lithium-ion battery. And the regulator
can be constructed by using external Nch MOS FET. The internal circuit of IC is composed by the voltage
detector, the reference voltage source, delay time control circuit, and the logical circuit, etc.
• Any products mentioned in this catalog are subject to any modification in their appearance and others for improvements without prior notification.
• The details listed here are not a guarantee of the individual products at the time of ordering. When using the products, you will be asked to check their specifications.
MITSUMI 3 to 5cells Li-ion/Li-polymer battery protection IC MM3575 Series
(4) The setting for three cell, for four cell, and for five cell protection can be set with the SEL pin.
(5) The charge and discharge of the battery can be controlled with SDC pin and SOC pin.
• Any products mentioned in this catalog are subject to any modification in their appearance and others for improvements without prior notification.
• The details listed here are not a guarantee of the individual products at the time of ordering. When using the products, you will be asked to check their specifications.
MITSUMI 3 to 5cells Li-ion/Li-polymer battery protection IC MM3575 Series
Pin Assignment
Top view
Pin No. Function
VSOP-24A
1 The input terminal of the power supply of IC.
The control terminal of output over charge detection.
2
ISOC<ISOCL OV=High impedance
The control terminal of output over discharge detection.
3
ISDC<ISDCL DCHG=Low
Input terminal connected to charger negative voltage.
4
Detected charger connection.
Charge control output terminal. Output type is Pch open drain.
5
Normal mode ”High” Overcharge mode ”High impedance”
Input terminal connected to discharge voltage.
6
Detected load connection.
Discharge control output terminal. Output type is CMOS.
7
Normal mode ”High” Overdischarge mode ”Low”
A terminal which sets delay time of discharging overcurrent and
VDD 1 24 V5
8 charging overcurrent detection/release. It is able to set delay time by
SOC 2 23 OUT5
connecting a condenser between VDD and COC terminals.
SDC 3 22 V4 Input of overcurrent detection. Detected overcurrent by sense resistor
VM2 4 21 OUT4
9 between CS1 pin and CS2 pin. And then the DCHG terminal outputs low
OV 5 20 V3
level, and it protects from large current discharging.
VM1 6 19 OUT3
DCHG 7 18 V2 10 Common terminal of overcurrent detection circuit.
COC 8 17 OUT2
The drive terminal of FET for regulator.
CS1 9 16 V1 11
CS2 10 15 OUT1
Connect to gate of FET
DRIVE 11 14 VSS The input terminal of regulator voltage.
12
REG_IN 12 13 SEL Connect to source of FET
This pin is for changing function for 3cell in series or 4cell in series , 5cell in series.
13
Connect VSS 5cells in series Connect V2 4cells in series Connect VDD 3cells in series
The input terminal of the negative voltage of V1 cell.
14
The input terminal of the ground of IC.
V1 cell balance control output terminal. Output type is CMOS.
15
Normal mode ”Low” Cell balance detect mode ”High”
The input terminal of the positive voltage of V1 cell, and the negative
16
voltage of V2 cell.
V2 cell balance control output terminal. Output type is CMOS.
17
Normal mode ”Low” Cell balance detect mode ”High”
The input terminal of the positive voltage of V2 cell, and the negative
18
voltage of V3 cell.
V3 cell balance control output terminal. Output type is CMOS.
19
Normal mode ”Low” Cell balance detect mode ”High”
The input terminal of the positive voltage of V3 cell, and the negative
20
voltage of V4 cell.
V4 cell balance control output terminal. Output type is CMOS.
21
Normal mode ”Low” Cell balance detect mode ”High”
The input terminal of the positive voltage of V4 cell, and the negative
22
voltage of V5 cell.
V5 cell balance control output terminal. Output type is CMOS.
23
Normal mode ”Low” Cell balance detect mode ”High”
24 The input terminal of the positive voltage of V5 cell.
• Any products mentioned in this catalog are subject to any modification in their appearance and others for improvements without prior notification.
• The details listed here are not a guarantee of the individual products at the time of ordering. When using the products, you will be asked to check their specifications.
MITSUMI 3 to 5cells Li-ion/Li-polymer battery protection IC MM3575 Series
Selection Guide
Detection voltage /Release voltage
Overdischarge detection
Discharging overcurrent
Discharging overcurrent
Overdischarge release
Overcharge detection
Short detection
Product name Protection mode
charge
voltage [mV]
voltage [V]
(MM3575***WBH) of disconnection
voltage [V]
voltage [V]
voltage [V]
voltage[V]
function
Prohibition of charge
MM3575A02WBH 4.250 4.175 2.800 2.900 0.100 0.200 0.400 –0.020 4.180 Prohibition
and discharge
Prohibition of charge
MM3575A08WBH 4.250 4.100 2.600 3.200 0.090 0.180 0.360 –0.030 4.180 Prohibition
and discharge
Disconnect detection
Discharging overcurrent
Discharging overcurrent
Discharging overcurrent
Disconnect release
Charging overcurrent
Charging overcurrent
delay time [msec]
Short detection
Product name
(MM3575***WBH)
tVDET1 tVREL1 tVDET2 tVREL2 tVDET3-1 tVDET3-2 tVREL3 tSHORT tVDET4 tVREL4 tVDET5 tVREL5 tVDET CB tVREL_CB
MM3575A02WBH 1.0 100 1.0 4.0 10.0 2.0 4.0 200 1024 128 200 4096 256 8.0
MM3575A08WBH 1.0 100 2.0 4.0 1536 60.0 4.0 200 100 128 200 4096 256 8.0
Please inquire to us, if you request a rank other than the above.
• Any products mentioned in this catalog are subject to any modification in their appearance and others for improvements without prior notification.
• The details listed here are not a guarantee of the individual products at the time of ordering. When using the products, you will be asked to check their specifications.
MITSUMI 3 to 5cells Li-ion/Li-polymer battery protection IC MM3575 Series
Application Circuit
· 5 cells protection circuit.
CELL+ SC Protector Pack+
RVDD
100
RV5 RSOC
1k 1M
24 V5 VDD 1 D1
ROG5
ROUT5 100k
V5 23 OUT5 SOC 2
QOUT5 RV4 RSDC RREG2
1k 1M 100
22 V4 SDC 3 G Q6
ROG4
ROUT4 100k S D
V4 21 OUT4 VM2 4
QOUT4 RV3 RVM2
1k 2.2k
20 V3 OV 5
ROG3 RVM1 G Q5
ROUT3 100k 100k S D
V3 19 OUT3 VM1 6
QOUT3 RV2
1k
18 V2 DCHG 7
ROUT2 ROG2 COOC
100k 0.001µF
V2 17 OUT2 COC 8
QOUT2 RV1
1k
16 V1 CS1 9 D2
ROUT1 ROG2
100k
V1 15 OUT1 CS2 10
TH QOUT1 D
CREG3 Q4
14 VSS DRIVE 11 RCS2 RCS1 RDG1 RDG2
CV5 CV3 CV1 G
S 1k 1k 100 100 REG
Thermistor 1µF 1µF 1µF
13 SEL REG_IN 12
RREG1
CVDD CV4 CV2 D3 CREG2
10µF 1µF 1µF RSEL CREG1 1.0µF Q1 ROV1
1k 2.2µF 3M DCHG-
CELL- RSENSE
5M Q2 Q3
D
2nd
G Protection
S
CHG-
• Any products mentioned in this catalog are subject to any modification in their appearance and others for improvements without prior notification.
• The details listed here are not a guarantee of the individual products at the time of ordering. When using the products, you will be asked to check their specifications.
MITSUMI 3 to 5cells Li-ion/Li-polymer battery protection IC MM3575 Series
MM3575(2)
RV10 RSOC2
1k 1M
24 V5 VDD 1
ROG10
ROUT10 100k
V10 23 OUT5 SOC 2
QOUT10 RV9 RSDC2
1k 1M
22 V4 SDC 3
ROG9
ROUT9 100k
V9 21 OUT4 VM2 4
QOUT9 RV8
1k
20 V3 OV 5
ROUT8 ROG8
100k
V8 19 OUT3 VM1 6 RSOC1
QOUT8 RV7 4.7M
1k
18 V2 DCHG 7
ROG7
ROUT7 100k
V7 17 OUT2 COC 8 D3
QOUT7 RV6
1k
16 V1 CS1 9 RSDC1
ROG6 4.7M
ROUT6 100k
V6 15 OUT1 CS2 10 D1
QOUT6
14 VSS DRIVE 11
RREG3
CV10 CV8 CV6 100
1µF 1µF 1µF 13 SEL
REG_IN 12
CVDD2 CV9 CV7
10µF 1µF 1µF RSEL2 RGND RREG4 Q7
1k 1k 1k D
RVM2-2 G
RVDD1100 200k S
MM3575(1)
RV5
1k
24 V5 VDD 1
ROG5
ROUT5 100k
V5 23 OUT5 SOC 2
QOUT5 RV4
1k
22 V4 SDC 3 G Q6
ROG4
ROUT4 100k S D
V4 21 OUT4 VM2 4
QOUT4 RV3 RVM2
1k 2.2k
20 V3 OV 5 G
ROG3 RVM1 Q5
ROUT3 100k 100k S D
V3 19 OUT3 VM1 6
QOUT3 RV2
1k
18 V2 DCHG 7
ROG2
ROUT2 100k CCOC1
V2 17 OUT2 COC 8 0.001µF RREG2
100
QOUT2 RV1
1k
16 V1 CS1 9 D2
ROG1
ROUT1 100k
V1 15 OUT1 CS2 10
QOUT1 CREG3 D
14 VSS DRIVE 11 RCS2 RCS1 RDG1 RDG2
CV5 CV3 CV1 G 1k 1k 100 100 REG
RSEL1 1µF 1µF 1µF Q4 S
13 SEL REG_IN 12
1k
CVDD1 CV4 CV2 RREG1
10µF 1µF 1µF RSEL1 D4 CREG2
CREG1 1.0µF Q1 ROV1
1k 2.2µF 3M DCHG-
CELL- RSENSE
5m Q2 Q3
CHG-
• Any products mentioned in this catalog are subject to any modification in their appearance and others for improvements without prior notification.
• The details listed here are not a guarantee of the individual products at the time of ordering. When using the products, you will be asked to check their specifications.