Professional Documents
Culture Documents
Bolt Capacities: Non-Preloaded Ordinary Bolts
Bolt Capacities: Non-Preloaded Ordinary Bolts
BS 4190: 2001
NON-PRELOADED ORDINARY BOLTS
Diameter Tensile Tension Shear Bearing Capacity in kN (Minimum of Pbb and Pbs)
of Stress Capacity Capacity End distance equal to 2 x bolt diameter.
Bolt Area Nominal Exact Single Double
0.8Atpt Atpt Shear Shear Thickness in mm of ply passed through.
At Pnom Pt Ps 2Ps
mm mm2 kN kN kN kN 5 6 7 8 9 10 12 15 20 25 30
12 84.3 16.2 20.2 13.5 27.0 27.6 33.1 38.6 44.2 49.7 55.2 66.2 82.8 110 138 166
16 157 30.1 37.7 25.1 50.2 36.8 44.2 51.5 58.9 66.2 73.6 88.3 110 147 184 221
20 245 47.0 58.8 39.2 78.4 46.0 55.2 64.4 73.6 82.8 92.0 110 138 184 230 276
This material is copyright - all rights reserved. Reproduced under licence from The Steel Construction Institute on 26/1/2006
22 303 58.2 72.7 48.5 97.0 50.6 60.7 70.8 81.0 91.1 101 121 152 202 253 304
24 353 67.8 84.7 56.5 113 55.2 66.2 77.3 88.3 99.4 110 132 166 221 276 331
27 459 88.1 110 73.4 147 62.1 74.5 86.9 99.4 112 124 149 186 248 311 373
30 561 108 135 89.8 180 69.0 82.8 96.6 110 124 138 166 207 276 345 414
Values in bold are less than the single shear capacity of the bolt.
Values in italic are greater than the double shear capacity of the bolt.
Bearing values assume standard clearance holes.
If oversize or short slotted holes are used, bearing values should be multiplied by 0.7.
If long slotted or kidney shaped holes are used, bearing values should be multiplied by 0.5.
C - 232a