Professional Documents
Culture Documents
Hydrostatic Test Pressure Calibration (ASME B31.3) : Authorized by
Hydrostatic Test Pressure Calibration (ASME B31.3) : Authorized by
(ASME B31.3)
Authorized By:
____________________________
Senior Inspector
Methanex Corporation
Medicine Hat, AB
Copy: 01
Revision Date: January 7, 2000
\\mxcmhtnt1\inetpub\wwwroot\procedures\maintenance\inspection\nde\lt-07.doc
TABLE OF CONTENTS
HYDROSTATIC TEST PRESSURE CALIBRATION
The hydrostatic test pressure at any point in the piping system shall be as follows:
For design temperature exceeding the test temperature, the minimum test pressure shall be calculated by the
equation below, except that the value of ST/S shall not exceed 6.5.
PT = 1.5 P ST/S
(ST/S) MAX =
PT = 1.5 P (ST/S) MAX
=
=
Round Up To Nearest 5 psig
Hydrostatic Test Pressure = psig