Professional Documents
Culture Documents
Control Philosophy For CW
Control Philosophy For CW
CONTROL PHILOSPHY
PROJECT CODE 1415-05 FOR COOLING WATER
EQUIP. SPEC. No. FC1415-05M0702 SYSTEM
CONTROL PHILOSPHY
FOR
COOLING WATER SYSTEM
DOCUMENT NO.
FC1415-05M0702
CUSTOMER
HUNG HUI CONST. & TRADING JSC-
VIETNAM
A common Cooling water system is provided to meet cooling water requirement of generator
bearing lub. oil system & shaft seal as pressure requirement of the cooling water system can
be made with available penstock pressure, it is proposed to use the water directly from
penstock. Application, description & scheme are given below. This description is to be read
with drawing No.F3C1415-05M0601
1.0 APPLICATION
Cooling water is required for following purpose.
1.1 Heat Exchanger of Generator Bearing lub. oil system.
1.2 Shaft Seal.
2.0 DESCRIPTION
For applications stated above, pressurized cooling water is required. Water for this purpose is
tapped from penstock of upstream of MIV. A ball valve is provided at the takeoff point of the
penstock and a common header shall be made.
A Globe valves is provided in common header line, which shall be used for regulating the
flow. A pressure gauge shall be provided in common header line for local indication.
1 No. Duplex coarse basket filter (500 micron) is provided in common header line for coarse
filtration of the water. Normally one element of duplex coarse basket filter remains in circuit
and other shall be standby. After duplex coarse basket filter Pressure reducing valves (1
main+1 standby) are provided in the common header line to reduce the inlet pressure
(penstock pressure) to 3.0 - 4.0 bar (system pressure). Isolation valves (Gate type) shall be
provided before and after Pressure reducing valve for isolation purpose during maintenance.
A Pressure relief valve is also provided for the safety of the system in the event of
malfunctioning of pressure reducing valve. A pressure gauge is provided after pressure
reducing valve to indicate the reduced system pressure.
1 No. Duplex fine basket filter (100 micron) is provided for supplying water to Shaft Seal &
Generator Bearing lube oil heat exchange. Normally one element of duplex fine basket filter
remains in circuit and other shall be standby. Duplex filter are basket type & manually change
over, back flashing also can be done by manually operating the back flash valve. A pressure
gauge is provided in line for local indication after fine filter to indicate the system pressure.
After bifurcation line, a Globe valve is provided for regulating the flow each unit. A pressure
gauge and a switch is provided in line for local indication to indicate the unit system pressure
and give low switching contact to control panel in case of low pressure.
-------------