Professional Documents
Culture Documents
Armado 335 Mando Final
Armado 335 Mando Final
Página 1 de 15
Cerrar SIS
Pantalla anterior
Producto: EXCAVATOR
Modelo: 335F EXCAVATOR SGJ
Configuración: 335F L Excavator SGJ00001-UP (MACHINE) POWERED BY C7.1 Engine
Desarmado y Armado
320GC, 320, 323, 325, 326 and 335 Excavators Machine Systems
Número de medio -M0080364-03 Fecha de publicación -01/11/2017 Fecha de actualización -20/11/2017
i06999809
Assembly Procedure
Reference: Special Instruction, "Visual Service Procedures - Colors and Symbols" M0066576
Table 1
Required Tools
Tool Part Number Part Description Qty
A 1P-2420 Transmission Repair Stand 1
B 439-3938 Link Bracket 3
D 138-7574 Link Bracket 2
F 5P-3931 Anti-Seize Compound -
G 126-3994 Duo-Cone Seal Installer As 1
Note: Apply a light film of hydraulic oil to all components before assembly.
1. Install the final drive sprocket if the sprocket was removed from the main housing.
Illustration 1 g06193276
Illustration 2 g06193282
Note: The rubber seals and all the surfaces that contact the seals must be clean and dry. After
installation of the seals, put clean SAE 30 oil on the contact surfaces of the metal seals.
Illustration 3 g06193284
Illustration 4 g06193277
Illustration 5 g06193278
(a) Bearing surface
(b) Housing surface
Use a suitable press and a spacer to apply a load of 4000 kg (8819 lb) on the bearings. Rotate the
housing to seat the bearings.
Use a depth micrometer to measure the step length between the bearing surface and the housing
surface. Take measurements at several different locations around the housing. Compute the average of
the measured dimension and record the number. Call this dimension (X).
Illustration 6 g06193279
Use a depth micrometer to measure the step length of the coupling gear. Take measurements at several different locations
around the gear. Compute the average of the measured dimensions and record the number. Call the dimension (Y).
The thickness of the shims is equal to (X-Y) ± 0.05 mm (0.002 inch).
Note: Use no more than two shims. If two shims are required, install the thinner shim next to the gear.
Illustration 7 g06193298
Illustration 8 g06193302
Illustration 9 g06193303
Illustration 10 g06193641
Illustration 11 g06193647
Make a stake mark on each side of the spring pin hole in the carrier. Each stake mark should be approximately 1.50 mm
(0.059 inch) from the outside diameter of the spring pin hole.
Illustration 12 g06193648
Illustration 13 g06193649
Illustration 14 g06193650
Illustration 15 g06193651
Illustration 16 g06193653
Illustration 17 g06193654
Illustration 18 g06193655
Illustration 19 g06193656
Make a stake mark on each side of the spring pin hole in the carrier. Each stake mark should be approximately 1.50 mm
(0.059 inch) from the outside diameter of the spring pin hole.
Illustration 20 g06193657
Illustration 21 g06193658
Illustration 22 g06193661
Illustration 23 g06193662
Illustration 24 g06193663
Illustration 25 g06193665
End By:
Copyright 1993 - 2020 Caterpillar Inc. Sun Feb 16 12:36:15 EST 2020
Todos los derechos reservados.
Red privada para licenciados del SIS.