Professional Documents
Culture Documents
Panasonic Ey7440 Manual de Usuario Páginas 7 9
Panasonic Ey7440 Manual de Usuario Páginas 7 9
Panasonic Ey7440 Manual de Usuario Páginas 7 9
Alignment marks
--
Bit-locking Function
1. With the trigger switch not engaged
Speed Selection and a screwdriver bit locked in
Choose a low or high speed to suit place, the tool can be used as a
the use. manual screwdriver (up to 22.6
HIGH
N·m, 230 k f-cm, 199 in-lbs).
LOW There will be a little play in the
chuck, but this is not a malfunction.
2. This feature is handy for tightening
screws that require more torque than
The more the variable speed control the maximum torque of the driver
trigger is pulled, the higher the speed (position on the clutch), for confirm-
becomes. ing the tightness of a screw or to
loosen an extremely tight screw.
CAUTION:
Check the speed selector switch
before use.
U se at low speed when high
torque is needed during operation.
(Using at high speed when high
torque is required may cause a
motor breakdown.)
Do not operate the speed selector
switch (LOW-HIGH) while pulling
on the speed control trigger. This How to Use the Belt Hook
can cause the rechargeable bat-
tery to wear quickly or damage the WARNING!
internal mechanism of the motor. • Be sure to attach the belt hook se
* See specifications for “RECOM curely to the main unit with the screw
MENDED CAPACITIES”. firmly fastened. When the belt hook
is not firmly attached to the main unit,
NOTE: the hook may disconnect and the
When the brake operates, a braking main unit may fall.
sound may be heard. This sound This may result in an accident or
indicates engagement of the bit lock. injury.
CAUTION: • Periodically check screw for tightness.
To prevent excessive temperature If found to be loose, tighten firmly.
increase of the tool surface, do • Be sure to attach the belt hook firmly
not operate the tool continuously and securely onto a waist belt or other
using two or more battery packs. belt. Pay attention that the unit does not
The tool needs cool-off time before slip off the belt. This may result in an
switching to another pack. accident or injury.
Do not close up vent holes on the • When the main unit is held by the
sides of the body during operation. belt hook, avoid jumping or running
Otherwise, the machine function is with it. Doing so may cause the hook
adversely affected to cause a failure. to slip and the main unit may fall.
Do NOT strain the tool (motor). This This may result in an accident or
may cause damage to the unit. injury.
--
--