Professional Documents
Culture Documents
Panasonic Ey7440 Manual de Usuario Páginas 10 12
Panasonic Ey7440 Manual de Usuario Páginas 10 12
Panasonic Ey7440 Manual de Usuario Páginas 10 12
[Battery Pack]
For Appropriate Use of Bat
tery pack
Liion Battery pack (EY9L40)
• For optimum battery life, store the
Li-ion battery pack following use with-
out charging it.
- 10 -
Charging
Common Cautions for the Li-
ion/Ni-MH/Ni-Cd Battery Pack
NOTE: 3. During charging, the charging lamp will
be lit.
• When charging a cool battery When charging is completed, an inter-
pack (below 0°C (32°F)) in a warm nal electronic switch will automatically
place, leave the battery pack at the be triggered to prevent overcharging.
place and wait for more than one • Charging will not start if the battery
hour to warm up the battery to the pack is warm (for example, immedi-
level of the ambient temperature. ately after heavy-duty operation).
Otherwise battery pack may not be The orange standby lamp will be
fully charged. flashing until the battery cools down.
• Cool down the charger when charging Charging will then begin automati-
more than two battery packs consecu- cally.
tively.
• Do not insert your fingers into con- 4. The charge lamp (green) will flash
tact hole, when holding charger or slowly once the battery is approxi-
any other occasions. mately 80% charged.
5. When charging is completed, the
CAUTION: charging lamp will start flashing quickly
To prevent the risk of fire or damage in green color.
to the battery charger. 6. If the temperature of the batter pack is
• Do not use power source from an 0°C or less, charging takes longer to
engine generator. fully charge the battery pack than the
• Do not cover vent holes on the standard charging time.
charger and the battery pack. Even when the battery is fully charged,
• Unplug the charger when not in it will have approximately 50% of the
use. power of a fully charged battery at nor-
mal operating temperature.
Li-ion Battery Pack 7. If the power lamp does not light imme-
NOTE: diately after the charger is plugged in,
Your battery pack is not fully charg or if after the standard charging time the
ed at the time of purchase. Be sure charging lamp does not flash quickly in
to charge the battery before use. green, consult an authorized dealer.
8. If a fully charged battery pack is
Battery charger (EY0L80) inserted into the charger again, the
1. Plug the charger into the AC outlet. charging lamp lights up. After sever-
al minutes, the charging lamp may
NOTE: flash quickly to indicate the charging
Sparks may be produced when the is completed.
plug is inserted into the AC power
supply, but this is not a problem in Ni-MH/Ni-Cd Battery Pack
terms of safety.
NOTE:
2. Insert the battery pack firmly into the When you charge the battery pack
charger. for the first time, or after prolonged
1 Line up the alignment marks and storage, charge it for about 24
place the battery onto the dock on hours to bring the battery up to full
the charger. capacity.
2 Slide forward in the direction of the
arrow.
- 11 -
LAMP INDICATIONS
Green Lit
Charger is plugged into the AC outlet.
Ready to charge.
Green Flashing Quickly
Charging is completed. (Full charge.)
Green Flashing
Battery is approximately 80% charged. (Usable charge.
Li-ion only)
Green Lit
Now charging.
Orange Lit
Battery pack is cool.
The battery pack is being charged slowly to reduce the load
on the battery. (Li-ion only)
Orange Flashing
Battery pack is warm. Charging will begin when temperature
of battery pack drops.
If the temperature of the battery pack is –10°C or less, the
charging status lamp (orange) will also start flashing. Charging
will begin when the temperature of the battery pack goes up (Li-
ion only)
Charging Status Lamp
Left: green Right: orange will be displayed.
Both Orange and Green Flashing Quickly
Charging is not possible. Clogged with dust or malfunction of
the battery pack.
- 12 -