Download as pdf or txt
Download as pdf or txt
You are on page 1of 1

MB Truck Key Programming Device v.1.

0
20 August, 2013

Device designed to program keys for Mercedes-Benz trucks. Device works fast and
automatically. You can program up to 8 keys. No PIN or model selection needed. Device is
Internet updateable.

Attention! The device is not intended for illegal use.

SUPPORTED MODELS (1996-2011):

ГРУЗОВИКИ АВТОБУСЫ
ACTROS EvoBUS
ATEGO CITO
AXOR CITARO
ECONIC

HOW TO USE:

1. Connect device to OBD connector. RED and then GREEN LED must lit. Device ready
to work.
2. Insert key and turn ignition ON.
3. Press and hold button on the device for 5 seconds.
4. Green led will start to blink and short beeps must be heard.
5. When device starts blinking by GREEN/ORANGE colors with long beeps - turn
ignition OFF.
6. After ignition OFF, device will blink GREEN with short beeps.
7. When device starts blinking by GREEN/ORANGE colors with long beeps - turn
ignition ON.
8. Successful programming follows by constant GREEN light and short beeps.
9. If programming fails you will her long constant beep while all of LEDs are off.

TECH TIPS:

 Repeat all of above to program next key (you can program up to 8 keys).
 You can program used keys or MEGAMOS 13 (ID13, SILCA13) transponders.
Transponders preparing not needed.
 For old truck and EvoBUS use the optional cable.

Welcome to visit our website www.autokeydevices.com to check for new products!

You might also like