BILL OF MATERIAL
INTERMEDIATE SERVICE KIT 546669-05
Description
223404-82 [ORING
Quantity
569415-03 | SILICONE GREASE 25G
SEAL RING
RECTANGULAR RING
541691-02,
543446-03
545800-01_ [RECTANGULAR RING
3 223406-14 | ORING 2
4 260104-91 RING (223406-34) 2
5 537086-03 | MOLYKOTE PASTE 1006 1
54580003 [RECTANGULAR RING
'545800-04 | SEAL RING (545800-02)
94587101 | VALVE PLUG
223406-22
223406-35Intermediate service kit 546669-05INFORMATION
Bad condition of bowl hood nylon seal ring can cause leakage of process liquid
from the bow!
Replace bowl hood seal ring at each
Intermediate Service.
Maximum permitted indentation of seal
ring is Imm
Knock out the old seal ring with pin
inserted in the holes intended for this
purpose
Fitting:
Press the seal ring into the groove with
straight planed board, which should be
placed across the ring. Knock carefully on
the board directly above the ring, first on
‘one side and then on the other side of the
ring
Turn the board by steps and drive the ring
into the groove as evenly as possible
NOTE
If the ring is too narrow, place it in hot water (70-80°C) for about 5 minutes. If
it is too wide, it will shrink after drying in 80-90°C for about 24 hours.
Deformation of seal is natural for nylon. If deformation causes problems during
fitting, place in hot water for about | minute and then seal will restore to it
proper shape