Professional Documents
Culture Documents
Aiwa TV 1402 Manual de Usuario 5 6
Aiwa TV 1402 Manual de Usuario 5 6
Aiwa TV 1402 Manual de Usuario 5 6
SUBJECT
Notes on repairing flat CRT TV set REF.No. :G − 99 − 076 − E0
<CONTENTS>
Pay attention to the following notes when repairing flat CRT a TV set.
When repairing a unit, DO NOT LEAVE the degaussing cable disconnected.
Conventional TV sets allow repairing work with a degaussing cable removed.
When repairing a TV set with flat CRT, however, the instruction below must be followed.
The instruction is provided on the service manual also.
Make this known to all staff concerned.
Notes on repairing:
DO NOT turn on the power of a TV set with a flat CRT when a degaussing coil is removed.
Turning on the power of a unit with neither degaussing coil or dummy load results in
opening a fixed resistor R848, which is inserted in parallel to the degaussing coil.
The following shows relations between the models concerned and the cement −resistors:
Also pay attentions to information about the flat CRT models to be released in the future.
Component values of the dummy resistors will be announced as occasion arises, and will be
contained in the service manual. Always take notice of the information.
SUBJECT
Notes on repairing REF.No. :G − 99 − 076 − E1
<CONTENTS>
Pay attention to the following notes when repairing the TV− F2400/F2000.
Note :The cement −resistor is not installed, if the serial number of unit is not included in
table above.