Professional Documents
Culture Documents
Batteries Answer
Batteries Answer
In answering item 44, 45 refer to figure 2D. each cell is 1.5V and has a capacity of
1/8 ampere...What type of connection is used to combine the cells?Required to
answer. Single choice.
(1 Point)
series
parallel
series-parallel
2929,
To flush a hydrometer, which of the following liquids should be used?Required to
answer. Single choice.
(1 Point)
sulfuric acid
salt water
fresh water
a solution of baking soda and water
3030,
The lead-acid cell is an example of which of the following types of cells?Required
to answer. Single choice.
(1 Point)
The dry cell
The voltaic cell
The primary cell
The secondary cell
3131,
Select the phrase from the list describes the part of the a cell -
CONTAINERRequired to answer. Single choice.
(1 Point)
negative electrode
positive electrode
solution acting upon the electrode
mounting for the electrode
3232,
What is the (a) voltage output and (b) current capacity of the circuit?Required to
answer. Single choice.
(1 Point)
(a) 1.5Volts (b) 1.5Amperes
(a) 4.5Volts (b) 1/2Ampere
(a) 9Volts (b) 1/4Amperes
(a) 18Volts (b) 1/8Amperes
3333,
A battery with capacity of 600 ampere-hours should provide 3 amperes for
maximum of how many hoursRequired to answer. Single choice.
(1 Point)
100 hr
200 hr
300 hr
600 hr
3434,
If violent gassing occurs during the charging of a battery, which of the following
actions should be takenRequired to answer. Single choice.
(1 Point)
Increase the room ventilation
decrease the room temperature
increase the charging rate
decrease the charging rate
3535,
How should the dry cell be stored to obtain maximum shelf life?Required to
answer. Single choice.
(1 Point)
In a dark container
In a heated cabinet
in a ventilated area
in a refrigerated space
3636,
In answering 55 to 58 Identify the description based on the type of battery
charged... INITIAL CHARGERequired to answer. Single choice.
(1 Point)
Used in emergency only
Used periodically as part of a maintenance routine
Used to keep a battery at full charge while the battery is idle
Used after electrolyte is added to a dry-shipped battery
3737,
What is the first step in performing maintenance on a secondary-cell
battery?Required to answer. Single choice.
(1 Point)
Check the level of the electrolyte
check the technical manual for information on the specific type of battery
Check the terminals for cleanliness and good electrical connection
check the battery case for cleanliness and evidence of damage
3838,
In answering item 41, 42 refer to figure 2C. each cell is 1.5V and has a capacity of
1/8 ampere....... What type of connection is used to combine the cells?Required to
answer. Single choice.
(1 Point)
Series
Parallel
Series-parallel
3939,
In answering item 39, 40 refer to figure 2B. each cell is 1.5V and has a capacity of
1/8 ampere.......What type of connection is used to combine the cells?Required to
answer. Single choice.
(1 Point)
series
parallel
series-parallel
4040,
When all the lead sulfate in a lead-acid cell is converted to sulfide acid, lead
peroxide, and sponge lead, what is the condition of the cell?Required to answer.
Single choice.
(1 Point)
Fully charged
Discharged
Sulfated
Unuasble
4141,
A battery is rated according to a 20 hour rate of discharge at 300 ampere hours.
Which of the following currents is the maximum current that will allow the battery
to deliver its rated capacity?Required to answer. Single choice.
(1 Point)
15 amperes
20 amperes
25 amperes
30 amperes
4242,
The cell is dischargingRequired to answer. Single choice.
(1 Point)
A,C,E,H
A,D,E,G
B,C,F,G
B,D.F.H
4343,
Which of the following types of routine charges follows the nameplate data in
restoring a battery to its charged condition during the ordinary cycle of
operations?Required to answer. Single choice.
(1 Point)
Initial
floating
normal
fast
4444,
Of the following types of cells, which one is a primary cell?Required to answer.
Single choice.
(1 Point)
Nickel cadmium
Silver Zinc
Lithium Oganic
Silver Cadmium
4545,
Which of the following is caused by local action in a cell?Required to answer.
Single choice.
(1 Point)
Shelf life is reduced
hydrogen is generated in large quantity
Impurities rise to the surface of the electrolyte
Mercury coating of the zinc electrode is worn away
4646,
What is the most common use of a silver zinc cell?Required to answer. Single
choice.
(1 Point)
Flashlight batteries
Automobile batteries
aircraft storage batteries
emergency equipment batteries
4747,
Which of the following is the purpose o fan electrical cellRequired to answer.
Single choice.
(1 Point)
To change mechanical energy to electrical energy
To change chemical energy to electrical energy
To change electrical energy to mechanical energy
To change electrical energy to chemical energy
4848,
The blotting paper in a dry cell serves, which of the following purposes?Required
to answer. Single choice.
(1 Point)
Separates the paste from the zinc
Permits the electrolyte from the paste to filter through the zinc slowly
both 1 and 2 above
keeps the electrolyte dry
4949,
Which of the following describes the shorting of a cell?Required to answer. Single
choice.
(1 Point)
Decreasing the length of a cell
connecting the anode and cathode together without a load
Using the cell below its full potential
providing a recharge voltage that is not sufficient to recharge the cell
5050,
What caused hydrogen to be attracted to the anode of a primary cell when the
cell is discharging?Required to answer. Single choice.
(1 Point)
A negative charge caused by a loss of electrons
A negative charge caused by an excess of electrons
A positive charge caused by a loss of electrons
A positive charge caused by an excess of electrons
5151,
Which of the following factors should be considered when selecting a primary
cell as a power source?Required to answer. Single choice.
(1 Point)
Power requirement
Type of electrolyte used
container material
all of the above
5252,
Which one of the following safety precautions for batteries is NOT
correct?Required to answer. Single choice.
(1 Point)
Terminal should be electrically connected together before transporting a battery
Care should be taken to prevent the spilling of electrolyte
smoking, open flames, and electrical sparks are prohibited around charging batteries
Protective clothing, such as rubber apron, rubber gloves, and face shield, should be worn when
working on batteries
5353,
What is/are the advantage(s) of using a manganese-dioxide-alkaline-zinc cell
over the zinc-carbon cell?Required to answer. Single choice.
(1 Point)
Battery voltage stability
Longer storage life
operates over a wide temperature range
all of the above
5454,
What determine the amount of current that a cell can deliver to the external
circuit?Required to answer. Single choice.
(1 Point)
The internal resistance of the cell only
The resistance of the external load only
The circuit resistance and and the internal resistance of the cell
The circuit capacitance and number of free electrons in the load
5555,
Which of the following actions will lower the internal resistance of a cell?Required
to answer. Single choice.
(1 Point)
Decreasing the size of electrodes
Increasing the size of the electrodes
increasing the spacing between the electrodes
increasing the resistance of the electrolyte
5656,
Which of the following diagram shows the proper connections for obtaining 6
volts an d1/4 ampere? (Each cell is 1.5Volts and has a capacity of 1/8
ampere).Required to answer. Single choice.
(1 Point)
1
2
3
4
5757,
Select the phrase from the list describes the part of the a cell -
CATHODERequired to answer. Single choice.
(1 Point)
negative electrode
positive electrode
solution acting upon the electrode
mounting for the electrode
5858,
Of the following characteristics, which one describes the mercury cell?Required to
answer. Single choice.
(1 Point)
It is physically one of the largest cells
it has a very stable output voltage
it is designed to be rechargeable
it produces a large amount of current but has a short shelf life
5959,
Which of the following is/are the difference (s) in the construction of a NICAD
CELL as compared to a lead-acid cell?Required to answer. Single choice.
(1 Point)
The electrolyte used
The material of the anode
The material of the cathode
All of the above
6060,
What is the (a) voltage output and (b) current capacity of the circuit?Required to
answer. Single choice.
(1 Point)
(a) 1.5Volts (b) 1/8ampere
(a) 1.5Volts (b) 5/8ampere
(a) 7.5Volts (b) 1/8ampere
(a) 7.5Volts (b) 5/8ampere