Download as docx, pdf, or txt
Download as docx, pdf, or txt
You are on page 1of 8

Configuration Manual STR800-4SO (New

HW)
STR800-4SO(New HW) LED Indications for Easy Troubleshooting:

LED Status Possible Reason Troubleshooting


LED Not Blinking SIM not detected Check SIM inserted properly in
device
LED Blinking RED APN1 & APN2 fields are Enable and configure APN1 &
desabled in device APN2 from WAN setting
configuration
LED Blinking Yellow Device Dialling to obtain the IP Usually within one minute SIM
address should get the IP address, if
LED blinking Yellow for long
time, check APN1 and APN2
configuration
LED Blinking GREEN Device received the IP address NA
on APN1 and APN2

Configuration:
Step-1:Check Signal Status: Goto: Basic Set >> WAN >> CELL0

After inserting the SIM card, please check below parameters


1, SIM detected: Yes
2, ACT : LTE/WCDMA
3, Signal: (singla value in dBm)
Step-2:Enable VPNM: Goto: Basic Set >> WAN >> CELL0
Step-3:Configure APN1& APN2 - Goto: Basic Set >> WAN >> CELL0

Please Note: APN1 Dial Number: *99***1#


APN2 Dial Number: *99***2#
Step-4:Check IP Address:Goto: Status Info>>Interface>> CELL0

Check IP address for APN1 and APN2, both IP address should be obtain by SIM card.
Step-5:Enable IP Pass-Through:

Step 6- TR069

Credentials:
ACS URL: http://10.59.144.97:7547/
CWMP USERNAME: easyCWMP
CWMP PASSWORD: easyCWMP
ACS USERNAME: easyCWMP
ACS PASSWORD: easyCWMP
Port 7547
Note:-
If FE uses own sim card on router then APN settings as below
1) Airtel

2) Vodafone
3) JIO

You might also like