Professional Documents
Culture Documents
Movax Dont Dos 2020
Movax Dont Dos 2020
DON’T DO’s
DON’T EXCEED REFUSAL, AVOID REBOUND
& DON’T EXCEED BEARING TEMPERATURES
Refusal
Less than 250 mm penetration in 4 minutes or 1 mm per
second.
Rebound
Rebound occurs when a large portion of the side grip pile
drivers’ energy is “bounced” back into the pile as a result of
force reflection at the pile tip due to the pile hitting a nearly
impenetrable layer or obstruction. The rebound forces will
be transferred back into the side grip pile driver as a result of
which the U-frame will start “jumping” relative to the vibro
box. In this situation driving should be stopped immediately.
REFUSAL
< 250 mm/4 min OR
< 1 mm/s
DON’T ATTEMPT TO HANDLE OR DRIVE
OVERSIZE PILES
DON’T OVERSPEED
– DON’T RUN TOO SLOW
Maximum RPM
Maximum operation speed during normal conditions is 3000
rpm. Running extensive periods at overspeed will result in
structural failures.
Minimum RPM
Also avoid revolutions below 2300 rpm as low frequencies
can cause stress on the structures leading to failures.
DON’T ROTATE THE PILE IN HORIZON-
TAL POSITION
360°
DON’T MISALIGN THE PILE WITH THE
MOVAX SIDE GRIP PILE DRIVER
NEVER grip the pile with only one of the two pairs of grip
pads or clamps as this could lead to twisting and damage of
the arms.
The MOVAX side grip pile driver must be clamping the pile
with its full length. The pile must be of the same thickness
between both side grip clamps. A difference in thickness
between the upper and lower clamp can cause breakage of
the side grip-mechanism.
The pile has to be fully inside the bottom clamp whilst
operating.
DON’T BEND THE PILE WITH THE BOTTOM
OR THE SIDE GRIP
Keep the MOVAX side grip pile driver and the pile parallel
when using the bottom grip. Twisting the pile with bucket
cylinder will add unwanted stress to the bottom grip and will
also damage the pile.
Jaws must be fully closed and have reached the set clamp
pressure type before starting the vibration;
• Sheet pile arms/clamps 320 bar
• Tube arms/clams 200 bar
NOTE! The pressure shown on the screen is only accurate when the jaws are
first pressurized (closed fully) or when vibrating - when the jaw button is relea-
sed or vibration is stopped the jaw pressure reading will start to drop.
DON’T USE THE SIDE GRIP PILE DRIVER
FOR ANYTHING BUT IT’S INTENDED USE
Movax Oy
Tölkkimäentie 10
FI-13130 Hämeenlinna, Finland
Tel. +358 3 628 070
Fax +358 3 616 1641
04/2020 – All rights reserved
service@movax.fi
www.movax.com