Professional Documents
Culture Documents
2016 SUBARU LEGACY - Knock Sensor and P0327
2016 SUBARU LEGACY - Knock Sensor and P0327
4. SENSOR
T4
T4
T1
(2)
T1 T3 (3)
T1
(4)
(12)
(6)
T1
(1)
(13) T1
(8)
(5)
T1
T1
(10)
(6)
T2
(7)
T1
(9)
T1
(11)
FU-20020
(1) Crankshaft position sensor (8) Exhaust oil flow control solenoid Tightening torque: N·m (kgf-m, ft-lb)
valve RH
(2) Knock sensor RH (9) Exhaust oil flow control solenoid T1: 6.4 (0.7, 4.7)
valve LH
(3) Knock sensor LH (10) Exhaust camshaft position sensor T2: 18 (1.8, 13.3)
RH
(4) Intake camshaft position sensor (11) Exhaust camshaft position sensor T3: 22 (2.2, 16.2)
RH LH
(5) Intake camshaft position sensor (12) Engine coolant temperature sen- T4: 25 (2.5, 18.4)
LH sor
(6) Intake oil flow control solenoid (13) Gasket
valve
(7) Oil temperature sensor
FU(H6DO)-7
Knock Sensor
FUEL INJECTION (FUEL SYSTEMS)
7. Knock Sensor
A: REMOVAL
1) Remove the collector cover.
(1) Carefully pull up the rear of collector cover at two positions (A).
(2) Carefully pull up the front of collector cover at two positions (B) while moving it forward.
(A) (A)
(B) (B)
IN-03659
2) Disconnect the ground terminal from battery sensor. <Ref. to RC-4, BATTERY, NOTE, Repair Contents.>
3) Remove the intake manifold. <Ref. to FU(H6DO)-24, REMOVAL, Intake Manifold.>
4) Disconnect the connector (A) from the knock sensor, and remove the knock sensor from the cylinder
block.
(A)
(A)
FU-08578
B: INSTALLATION
1) Install the knock sensor to the cylinder block, and connect the connector (A) to the knock sensor.
Tightening torque:
25 N·m (2.5 kgf-m, 18.4 ft-lb)
FU(H6DO)-52
Knock Sensor
FUEL INJECTION (FUEL SYSTEMS)
NOTE:
The knock sensor should be installed so that the center of the connector is positioned as shown in the figure
relative to the front of engine.
45
30 10
(A)
(A) FU-08641
2 1
EC-02799
FU(H6DO)-53
Electrical Component Location
ENGINE (DIAGNOSTICS)
2. SENSOR
(1) (2) (3) (4) (5) (6) (2)
(1) Mass air flow and intake air tem- (5) Crankshaft position sensor (8) Exhaust camshaft position sensor
perature sensor
(2) Intake camshaft position sensor (6) Knock sensor (9) Engine oil temperature sensor
(3) Manifold absolute pressure sensor (7) Battery sensor (10) Engine coolant temperature sen-
sor
(4) Electronic throttle control
EN(H6DO)(diag)-13
Diagnostic Procedure with Diagnostic Trouble Code (DTC)
ENGINE (DIAGNOSTICS)
ECM
34 1
17
1
E158
E158
E14 E48
1 2 3 4 5 6 7 8 9 10 11 12 13
14 15 16 17 18 19 20 21 22 23 24 25 26
1 2 27 28 29 30 31 32 33 34 35 36 37 38 39
40 41 42 43 44 45 46 47 48 49 50 51 52
53 54 55 56 57 58 59 60 61 62 63 64 65
EN-11112
EN(H6DO)(diag)-316
Diagnostic Procedure with Diagnostic Trouble Code (DTC)
ENGINE (DIAGNOSTICS)
EN(H6DO)(diag)-317
Diagnostic Procedure with Diagnostic Trouble Code (DTC)
ENGINE (DIAGNOSTICS)
1. OUTLINE OF DIAGNOSIS
Detect the open or short circuit of knock sensor.
Judge as NG if out of specification.
2. COMPONENT DESCRIPTION
(1)
(4) (5)
(A)
(2)
(3)
EN-08987
3. EXECUTION CONDITION
Secondary Parameters Execution condition
None
EN(H6DO)(diag)-318