Professional Documents
Culture Documents
Data Sheet For Absorber Reflux Drum (GTPT-V-250-003)
Data Sheet For Absorber Reflux Drum (GTPT-V-250-003)
Document No.TGP-JE-GTPT-250-EQ-DAT-0008
C02 5 Design Code: ASME BPVC.VIII Div.1 2019 Edition Design Life: Years 25
6 Medium: Gas and Condensate Ambient Temperature: °C Min. -1.4 Max. 47.6
7 Operating Temperature: °C -79 Min. Design Metal Temperature: °C -85
C02 8 Operating Pressure: barg 25/32.5(max) Medium: 6ZHHW 6RXU +LJK& :HW+6
C02 30 Code ASME BPVC.II 2019 Edition, ASTM Jacket Shell/Head: N/A
31 Shell: SA-240 316L Body Flange: N/A
32 Head: SA-240 316L Body Flange Gasket: N/A
33 Nozzle(Pipe): SA-312 TP316L Demister N/A
34 Nozzle(Plate): SA-240 316L Insulation Supports/Clips: SS 316L
35 Nozzle(Forged): SA-182 F316L Support: SA-36/SA-240 316L
2 Type of Support: 6DGGOH /XJ 6NLUW /HJ Mist Eliminator: <HV 1R
C02 3 Manway with Davit/Hinge: <HV 1R Separation Internals: <HV 1R
C02 9 Non-destructive Testing Fabrication Code: ASME BPVC.VIII Div.1 2019 Edition
10 Joint Category Test Means Test Ratio Grade NDE Code: ASME BPVC.V 2019 Edition
20 Nozzle Schedule
21 Flange
Nozzle Mark Qty. Size Service
22 Rating Type Face
29 HW 1 8" CL300 WN RF Handhole with blind flange and bolts, nuts, gasket
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
Project Name:
NOTE:
All dimensions are in mm except as noted.
Notes
1. Reference P&ID: TGP-JE-GTPT-250-PR-PID-0002.
2. The main approximate content in medium: CO2 in gas is 3.49%(mol).
3. Table with max. allowable nozzle loads shall be shown on the general arrangement drawing.
4. Flange bolts holes shall straddle vessel's north-south line and true vertical line.
)ODQJHJDVNHWVVHDWLQJIDFHILQLVKVKDOOEHȝPWRȝP$$5+
6. The hydrostatic test can only take place once the authorization certificate is obtained. CONTRACTOR pointed Tunisian Third Party Inspector
shall witness the hydrostatic test.
C02 7. Hydrostatic test pressure is at least equal to 1.5 times design pressure.
8. Proper position shall be reserved on the nameplate for third party inspector to stamp after hydrotest witness.
9. Picking and passivation shall be performed on the surface of the stainless steel.
10. VTC: Vendor to confirm.
C02 11. Anchor bolts material used for calculation shall conform to EN 10025 S355JR or ASTM A572 Grade 50.
12. Material certificate of EN10204 3.1 for pressure containing parts, and 2.2 for non-pressure parts are required.