Professional Documents
Culture Documents
Mpfiltri Icm 201.017
Mpfiltri Icm 201.017
1 Identify whether
your unit is a “K” or
Plug the control cable
from your USBi into the
6
non “K” verion. ICM power connection
K – Keypad and 128 x port.
64 pixel backlit display For hardwired or PLC
controlled applications,
refer to the full user manual
for instruction, then go to STEP 8.
2 Identify the
connection type on
your unit.
7
If you are using an MP Filtri USBi, connect
This can be found on the to your laptop using the USB cable.
product label on the side
A permanent DC supply may also be
of the ICM.
connected.
G1 - Minimess
G3 – ¼” BSP G4 – 7/16” UNF
USBi
ICM
3 Where flow
control is
USBi
DC
required fit ICM
your MP Filtri FC1
control valve.
See over page for
8
instructions then The ICM should now
continue to Step 4 be powered.
This will be indicated by
either the display
TEST
10
5 Check that all pressure
fittings are sufficiently tight
Once at working
system pressure,
as not to allow leakage. press the green
In the interests if safety, always button on the front
check this at low pressure if possible. Once panel (K-version only)
happy with the installation, isolate the up- of the ICM and it will perform a 120 second
stream pressure before continuing to STEP 6 test (factory set time).
*For full product, software and installation instructions see the ICM User manual. As a policy of continual improvement, MP Filtri reserve the right to alter
specifications without prior notice. Except as permitted by such license, no part of this publication may be reproduced, stored in a retrieval system or
transmitted in any form or means electronic, mechanical, recording, or otherwise, without prior written permission of MP Filtri UK Ltd.
FC1
Installation
P2 P2 P2 P2
The ICM can be installed in Flow Flow
series or in parrallel. Control Control
*For full product, software and installation instructions see the ICM user manual. As a policy of continual improvement, MP Filtri reserve the right to alter
specifications without prior notice. Except as permitted by such license, no part of this publication may be reproduced, stored in a retrieval system or
transmitted in any form or means electronic, mechanical, recording, or otherwise, without prior written permission of MP Filtri UK Ltd.
Typical Installation Guidelines
2x 7
Mounting
ICM Dimensions
2x 7
Mounting
DCR:
Doc No: 201 .017 Rev 01: