Professional Documents
Culture Documents
BDTM-160-V 5D Manual
BDTM-160-V 5D Manual
CONTENTS
6. References
Wiring Diagram
Inspection Results
DTM-160V Product Descriptions
1. Description of Product
The device is to display RPM of ENGINE and T/C upon each input signal after receiving
the signal outputted to voltage of ENGINE and T/C. This product raised precision by
using 16BIT ADC built in micro-process and made operation convenient by one-touch
setting availability of all ZERO, SPAN, RPM-TYPE with use of the button in front. Also
this product prevents RPM accuracy from decreasing due to temperature increase as
temperature compensation program is added in consideration of its being installed on
the side of engine.
2. Functional Descriptions
A. RPM-TYPE DISPLAY: USER can check the RPM-RANGE of engine.
B. DIGITAL SETTING Function: User can simply set up SPAN, ZERO, RPM-TYPE with
KEY. ( NOTE: You must fit ZERO(0V) and SPAN(6V) at the same time on SETTING,
then you can increase the precision of product when adding output of precise calibrator
as input. )
C. Internal Temperature DISPLAY: You can check internal temperature as it displays
product internal temperature.
(1)
DTM-160V Product Specifications
3. Product Specifications
Operation Ambient
-10℃~+60℃
Temperature
Storage Temperature -25℃~+70℃
Operation Ambient
Less than 90%
Humidity
Value 96(W)ⅹ96(H)ⅹ63(D) (UNIT:mm)
(2)
DTM-160V Front Plate Descriptions
4. Front Plate Descriptions
1
2
(3)
DTM-160V Setting Procedure 1
5. Setting Procedure
Enter into SETTING MODE and set up each ENG,T/C for ZERO Setting.
Enter into SPAN SETTING MODE and set up each ENG,T/C for
SPAN Setting.
Enter into RPM-TYPE SETTING MODE for final setting and set up
RPM-TYPE fit to the product.
Turn off power and on again and check operational status to see if
product is rightly saved according to setting
(4)
DTM-160V Setting Procedure 2
ENGINE
T/C
9
(With pressing )
TC:60000 ENG:1000
TC:40000 ENG:1200
TC:60000 ENG:1200
5. DISPLAY CHIP-TEMPERATURE
(With pressing)
6. DISPLAY RPM-TYPE
(With pressing)
DTM-160V Setting Procedure 4