Professional Documents
Culture Documents
Ae Ii
Ae Ii
3. If the output of an amplifier is 10 V and 100 mV from the output is fed back to the input,
then feedback fraction is ………..
a) 10
b) 1
c) 100
d) 15
10. With zero volts on both inputs, an OP-amp ideally should have an output ………..
a) equal to the positive supply voltage
b) equal to the negative supply voltage
c) equal to zero
d) equal to CMRR
11. A certain OP-amp has bias currents of 50 μA. The input offset current is ……..
a) 700 nA
b) 99.3 μA
c) 49.7 μA
d) none of these
12. The output of a particular Op-amp increases 8V in 12μs. The slew rate is …….
a) 90 V/μs
b) 0.67 V/μs
c) 1.5 V/μs
d) none of these
15. An integrating circuit is a simple RC series circuit with output taken across ………
a) Both R and C
b) R
c) C
d) None of the above
1. Explain with a circuit diagram the operation of a single tuned amplifier. Draw its gain
versus frequency curve. State features of stagger tuned amplifier. Mention its applications
(6+2+2)
2. Explain how voltage gain, input and output impedance of voltage shunt feedback is
effected? Explain the working principle of Darlington pair amplifier. What are the criteria
of critical coupling? (6+3+1)
3. Explain the working principle of RC phase shift oscillator. Draw the circuit diagram of
Emitter Follower and calculate its current gain.
(6+4)
4. In an Inverting amplifier op.amp of R1=100 Ω, Rf=100K Ω .
a) What will be the gain of an amplifier?
b) If an input of 3mV is given to a load of 1K what will be the output voltage and
load current?
c) If sine wave of 4mV peak to peak is given, How will be the output waveform?
d) Define CMRR, Slew Rate, Virtual ground, Output offset voltage.
(3+2+1+4)
5. a) Explain the operation of Integrator Circuit using Op-Amp. Show its output waveform
if triangular input is given to the circuit.
b)Explain Clipper operations using Op-Amp Circuit. (4+2+4)
6. Explain the working principle of monostable multivibrator using transistor. Draw the
internal block diagram of IC 555. (5+5)
7. What is relaxation oscillator? What is miller effect? Briefly explain the operation of
bootstrap circuit using neat circuit diagram and draw its output waveform. (2+2+6)
8. What is an Integrated Circuit? What are the advantages of IC over discrete circuit
designs? How will you fabricate diode, transistor, resistor and capacitor in IC? 5+5
9. Explain how square wave can be generated using IC555.Explain the operation of Colpitt
oscillator with necessary circuit diagram. What will be the frequency of such oscillator.
(5+5)
10. Write short note on (any two):
a)Photolithography b)Voltage follower c)Schmitt Trigger d)Wien Bridge Oscillator.
ANSWER
A.2 B.1 C.3 D.2 E.3 F.2 G.3 H.1 I.4 J.3 K.1 L.2 M.2 N.4 O.3 P.4 Q.1