Professional Documents
Culture Documents
H. V. NC: Satin White
H. V. NC: Satin White
H. V. NC: Satin White
NC
Satin White Product No.7214
APPLICATION DATA
The fast drying time combined with desirable physical
properties make it ideal for mass production of furniture. Mixing Ratio
N / A. (Single Pack)
Various shades can be tinted resulting in attractive,
light fast finishing coats for pleasant looking lacquered Product Preparation
pieces of furniture. Stir product well with a flat paddle. Thin to the required
viscosity and stir until homogeneous.
Easy application by conventional spray, airless spray
Thinning
and curtain coater.
Use - 7298 - H.Q. Lacquer Thinner LT 998.
The quantity of thinner to - 7298 - to add depends on the
PROPERTIES
application system used. Generally 50-100% thinner is
added to achieve a viscosity of 16 - 18 seconds Fc4., which
Appearance
is suitable for conventional spray.
High Viscosity Liquid.
Pot Life
Color
N / A.
White ( Pastel & Medium Shades can be tinted on
request.)
Application
Depends on the finish required but in general an
Pack Size
appropriate rate is between 130 - 170 g/sq. m.
5 ltr,20 Ltr. Cans & 200 Ltr. Drums
Application Equipment
Gloss
Can be applied by conventional air pressure spray, airless
55-65% @ 60 Deg. C.
and curtain coater.
Viscosity
Cleaning of Equipment
80 -100 KU
Clean all equipment immediately after use with suitable
thinner.
Specific Gravity
Approx. 0.970 kg/ ltr. - 0.995 kg/ ltr.
SAFETY INFORAMTION
This material is flammable and must not be exposed to
Flash Point
naked flames.
Less than 21 Deg. C.
See the material Safety Data Sheet and Product Label for
complete Safety and Precaution Requirements.
Drying
(@ 25 Deg. C. and 50% Relative Humidity.)
To Dust : 5 minutes
To Touch : 15 Min
Sandable ; N /A
To Hard Dry : 60 minutes
Storage information
Store in original sealed containers, indoors at
temperatures between 5 and 40 Deg. C. and a relative
humidity below 70%.
Shelf Life
12 months @ 25 Deg. C.
The information in this data sheet represent test results or experience under well defined conditions. Its accuracy or suitability under the actual conditions of any intended use is not guaranteed and
must be determined by the user. All advice given about this product is given in good faith. Since as we have no control over conditions of substrate and application, manufacturer and seller can not
accept any liability in connection with the use of the product relative to coverage, performance, injury or damage, unless we specifically agree in writing to do so. The information in this data sheet is
subject to change without notice and it is the user’s responsibility to ensure it is current. For further information and advice contact SIPCO Technical Services Department on Tel. (03) 847 2299, Fax
(03) 847 3780. Issue Date: June 2003