Professional Documents
Culture Documents
408 Mapesillm GB
408 Mapesillm GB
408 Mapesillm GB
EN 15651-1 EN 15651-2
sil
e
EN 15651-3 EN 15651-4
ap
M
Neutral mould-resistant
silicone sealant with
very low emission level
of volatile organic
compounds (VOC) for
stone and marble
Ma
Primer FD must be applied beforehand in
the case of prolonged immersion in water. Also, to protect the substrate from staining,
apply masking tape along the edges of the
If in doubt, please contact the MAPEI joint before extruding Mapesil LM.
Technical Services Department or carry
out preliminary tests beforehand. Regulate the depth of the joint to avoid
Mapesil LM sticking to the bottom by
Mapesil LM is particularly suitable for surfaces inserting Mapefoam polystyrene foam cord
sensitive to acids on which conventional neutral in the joint.
or acid sealants normally provoke changes in
colour or staining of the substrate. Application of Primer FD
If a coat of Primer FD is required, apply
Mapesil LM complies with EN 15651-1 norm the product with a small brush where
(“Sealants for internal and external façade required, leave it to dry for a few minutes
elements”) with performance rating so that the solvent evaporates and then
F-EXT-INT-CC, with EN 15651-2 norm apply Mapesil LM.
(“Sealants for glazing”) type G-CC, with
EN 15651-3 norm (“Sealants for joints in Application of Mapesil LM
sanitary areas”) type XS1 and EN 15651-4 Mapesil LM is available in 310 ml cartridges.
norm (“Sealants for pedestrian walkaways”) Cut the tip of the cartridge near the thread
with performance rating PW-EXT-INT-CC. and screw on the nozzle. Trim the tip of
the nozzle at 45° according to the width of
RECOMMENDATIONS joint required and insert the cartridge into a
• Do not apply Mapesil LM on rubber, suitable extrusion gun.
heavily-plasticised plastics or bitumen. Finish the surface of Mapesil LM with a
The oil and plasticising agents in the suitable damp tool or a tool dipped preferably
Sealing a butt joint substrate may migrate to the surface and in soapy water before the skin forms on the
on natural stone compromise the bond or penetrate into the surface.
sealant leading to a variation in colour and
mechanical characteristics.
PRODUCT IDENTITY
FINAL PERFORMANCE
MANHATTAN 2000
Ma Coloured
CEMENT GREY
MEDIUM GREY
TRANSPARENT
ANTHRACITE
SILVER GREY
BEIGE 2000
JASMINE
table
BLACK
WHITE
110
111
112
113
114
120
130
132
999
For further information, please refer to the the latest version of our Material Safety Data
Safety Data Sheet available upon request. Sheet.
®
Sealing a façade joint
with Mapesil LM