Professional Documents
Culture Documents
RS485 Product Manual
RS485 Product Manual
RS485 Product Manual
I. Product Schematic
2 Set button
Check and set IP address, voltage, current, temperature
and humidity alarm values.
3 UP button
Check and set IP address, voltage, current, temperature
and humidity alarm values.
monitor the total Current, Voltage, Power, Electrical Energy, Power Factor.
2. Custom Alarm:
When the total load current or total load Voltage, exceeds its threshold, and
Temperature/Humidity exceeds its threshold.
3. Cascade Connection:
RS485 Serial interface.
III.Hardware Instruction
1.The device will be buzz once power on, the LCD will display the total Current, Voltage,
Power, Electrical Energy, Power Factor, Temperature and Humidity.
2.Through the tap "up" or "down" will cycle through main information display device/
Check main information via "UP" or "DOWN" buttons.
address
Set address
Product Operating Manual
Use the "SET" to move the cursor to the target parameter, press button "SET" and
“UP/DOWN” to set.
After parameters setting, please move the cursor and select “YES”,then press “SET” to
save
Use the same way to set the voltage, current, Upper Limit and Lower Limit of
Temperature&Humidity. For Default page (page 06), move the cursor and select
“YES”,press “SET” to save, this is restore the default settings.
When the Alarm happen, the relevant parameters will flicker and buzz.
When the alarm happen, press any key will cancel buzz for one minute.