Professional Documents
Culture Documents
9.3 Standards and References
9.3 Standards and References
9.3 Standards and References
9.1.1 Standards
The requirements of the following standards are mandatory. In case of conflicting requirements within
these standards, the most stringent Saudi Aramco requirement shall apply.
GS 217/1994 (or later), Industrial Safety and Health Regulations – Equipment: Scaffolding
9.1.2 References
The following resources are a basis for many of the requirements of this section and may be
used for additional guidance and information.
ANSI Z359.1, Safety Requirements for Personal Fall Arrest Systems, Sub-systems
and Components
ASTM A53, Standard Specification for Pipe, Steel, Black and Hot-Dipped, Zinc-
Coated, Welded and Seamless
ASTM A123, Standard Specification for Zinc (Hot-Dip Galvanized) Coatings on Iron
and Steel Products
ASTM A370, Standard Test Methods and Definitions for Mechanical Testing of Steel
Products
ASTM A500, Standard Specification for Cold-Formed Welded and Seamless Carbon
Steel Structural Tubing in Rounds and Shapes
BS 1139: Part 1: Section 1.1: 1990 (or later), Specification For Steel Tube
BS 1139: Part 2: Section 2.1: 1991 (or later), Specification For Steel Couplers, Loose
Spigots and Base-Plates for Use in Working Scaffolds and Falsework Made of
Steel Tubes
BS 1139: Part 2: Section 2.2: 1991 (or later), Specification for Steel and Aluminum
Couplers, Fittings, and Accessories for Use in Tubular Scaffolding
BS 2482: 1981 (or later), Specification for Timber Scaffold Boards
BS 5973: 1993 (or later), Code of Practice for Access and Working Scaffolds and
Special Scaffold Structures in Steel
EN 39: 2001 (or later), Loose Steel Tubes for Tube and Coupler Scaffolds-Technical
Delivery Conditions
EN 74: 1998 (or later), Couplers, Loose Spigots and Base-Plates for Use in Working
Scaffolds and Falsework Made of Steel Tubes: Requirements and Test Procedures
EN 10219-1: 1997 (or later), Cold Formed Welded Structural Hollow Sections of Non-
Alloy and Fine Grain Structural Steels: Part 1. Technical Delivery Requirements
EN 10219-2: 1997 (or later), Cold Formed Welded Structural Hollow Sections of Non-
Alloy and Fine Grain Structural Steels: Part 2. Tolerances, Dimensions and
Standards and References
Sectional Properties
NASC Guidance Note SG4:00, The Use of Fall Arrest Equipment Whilst Erecting,
Altering, and Dismantling Scaffolding
United States Code of Federal Regulations 29 CFR, Part 1910, Subpart D, ”Walking-
Working Surfaces", Occupational Safety and Health Administration (OSHA):
OSHA 1910.24, Fixed Industrial Stairs
OSHA 1910.28, Safety Requirements for Scaffolding
OSHA 1910.29, Manually Propelled Mobile Ladder Stands and Scaffolds (Towers)
United States Code of Federal Regulations 29 CFR, Part 1915, Subpart I, ”Personal
Protective Equipment," Occupational Safety and Health Administration (OSHA):
United States Code of Federal Regulations 29 CFR, Part 1926, Subpart L, ”Scaffolds,"
Occupational Safety and Health Administration (OSHA):
United States Code of Federal Regulations 29 CFR, Part 1926, Subpart M, ”Fall
Protection," Occupational Safety and Health Administration (OSHA):