Professional Documents
Culture Documents
190-01007-k9 - 03 - ICA EC130
190-01007-k9 - 03 - ICA EC130
Dwg. Number:
190-01007-K9 Rev. 3
Record of Revision
Rev. Date Description of Change
1 10/17/2013 Initial Release.
Updated Figures in Section 2.8 and Appendix A, Added instructions to
2 3/22/2016
disable Airspace Altitude Labels.
Corrected references and added information about GMA 35c and
3 01/29/2020
Flight Stream 510.
Company Proprietary Information
This drawing and the specifications contained herein are the property of Garmin International or its
subsidiaries and may not be reproduced or used in whole or in part as the basis for manufacture or sale
of products without written permission.
Table of Tables
Table 1. Maintenance Intervals for GTNs and GMA 35 ........................................................................... 3
Table 2. Maintenance Intervals for Antennas Replaced Under this STC ................................................... 5
Table 3. Bill of Materials for GTN Navigators and Optional GMA Audio Panel ........................................... 8
Table 4. GTN Circuit Breaker Labels ................................................................................................... 11
Table 5. Bill of Materials for Circuit Breaker and GPS Switch in EC130T2 ............................................... 13
Table 6. Bill of Materials for Circuit Breaker and GPS Switch in EC130B4 ............................................... 15
Table 7. Typical Weight and Balance of GTN and GMA 35 Installed in EC130T2 .................................... 18
Table 8. Typical Weight and Balance of GTN and GMA 35 Installed in EC130B4 .................................... 19
1.2 Scope
This document provides the Instructions for Continued Airworthiness Eurocopter EC 130B4 and EC 130T2
rotorcraft, modified by the installation of the Garmin GTN 6XX/7XX, optional GMA 35/35c, and Flight
Stream 510 under the AML STC SR02120SE.
1.5 Definitions
The following terminology is used within this document:
1) ACO: Aircraft Certification Office
2) AEG: Aircraft Evaluation Group
3) BIT: Built-In Test
4) COM: Communications
5) CFR: Code of Federal Regulations
6) FAA: Federal Aviation Administration
7) GPS: Global Positioning System
8) ICA: Instructions for Continued Airworthiness
9) LED: Light Emitting Diode
10) LRU: Line Replaceable Unit
11) NAV: Navigation
12) MFD: Multi-Function Display
13) PMI: Principal Maintenance Inspector
14) POI: Principal Operations Inspector
15) STC: Supplemental Type Certificate
16) TSO: Technical Standard Order
17) WAAS: Wide Area Augmentation System
1.6 Terminology
Except where specifically noted, references made to the ‘GTN’ will equally apply to the GTN
625/635/650/725/750. Also, ‘GTN 7XX’ refers specifically to the GTN 725 and GTN 750, and ‘GTN 6XX’
refers specifically to the GTN 625, GTN 635, and GTN 650.
Except where explicitly noted, references made to the GMA 35 will be synonymous with the GMA 35 and
GMA 35c.
2. DISPLAY BACKLIGHT The display backlight LEDs are rated by the manufacturer as having a
usable life of at least 36,000 hours. This life may be more or less than the
ON CONDITION
rated time depending on the operating conditions of the GTN. Over time,
the backlight lamp may dim and the display may not perform as well in
direct sunlight conditions.
The user must determine by observation when the display brightness is not
suitable for its intended use. Contact the Garmin factory repair station when
the backlight lamp requires service.
5. VISUAL INSPECTION The GTN unit, GMA 35 (if installed), Flight Stream 510 (if installed),
switches, and wiring harnesses should be inspected to ensure continued
TO BE PERFORMED IN
integrity of the installation in alignment with Eurocopter Master Servicing
ALIGNMENT WITH THE
Manual (MSM 05-22-00)
EUROCOPTER EC130
600 FLIGHT HOUR Visually inspect the following to ensure continued installation integrity -
INSPECTION OR EVERY 1. Inspect the GTN unit(s) and GMA 35 for security of attachment,
24 MONTHS, WHICHEVER including visual inspection of mounting racks and rotorcraft instrument
COMES FIRST. panel or avionics console supporting structure to which the racks attach.
Verify the countersunk fastener heads are in full contact with unit
mounting rack holes. If a GTN Navigator is installed in the center
console, inspect the condition of the console and unit install rack around
the rivets. Repair damage as necessary in accordance with MTC 20-03-
190-01007-K9 Rev. 3 Page 4 of 22
Instructions for Continued Airworthiness GTN 6XX/7XX - Eurocopter EC130 Series
ITEM
DESCRIPTION/PROCEDURE
INTERVAL
06-407. Verify countersunk rivet head is fully seated into the unit
mounting rack fastener hole with no slack. For GTNs installed in the
instrument panel, re-torque fasteners 12 to 15 in-lbs if required. Verify
the electrical bond using the procedure in item 4 above. If installed,
ensure the Flight Stream 510 is properly oriented (label facing right),
fully inserted, and locked into position in the card slot on the front-left
side of the GTN.
2. Inspect for signs of corrosion, and if corrosion is found, treat in
accordance with Section 04, Cleaning, Protective Treatment, and
Painting of Eurocopter Standard Practices Manual MTC 20-04
3. Inspect all switches, knobs, and buttons for damage. If knobs or
buttons are missing or damaged, return the unit to Garmin for repair.
4. Inspect placards and switch labels. Ensure that they are legible and
properly adhered. Replace any damaged labels as necessary.
5. Inspect condition of wiring, shield terminations, routing, and
attachment/clamping. Correct any issues identified by replacing
damaged wiring and re-attaching as necessary.
6. Check the fan intake slots on the sides and bottom of the GTN unit’s
bezel for dust, dirt, or obstructions. Clean as needed
In the EC 130 B4, the circuit breakers for the GTN 6XX are located in the 16 Alpha circuit breaker panel
located on top of the instrument panel support, or the in the 31/32 Alpha Secondary circuit breaker panel
located on the right hand side of the instrument panel support shown in Figure 5.
Figure 7 GTN 1 ON/OFF Switch and GTN 2 Circuit Breaker Installation in EC130T2
Figure 9 GTN 1 ON/OFF Switch and GTN 2 Circuit Breaker Installation in EC130B4
190-01007-K9 Rev. 3 Page 15 of 22
Instructions for Continued Airworthiness GTN 6XX/7XX - Eurocopter EC130 Series
Figure 10 Typical GTN Circuit Breaker Location in Eurocopter EC130B4
Table 7 Typical Weight and Balance of GTN and GMA 35 Installed in EC130T2
WEIGHT LONGITUDINAL LATERAL
ITEM DESCRIPTION PART NUMBER
[LB] ARM [IN] MOMENT ARM [IN] MOMENT
1 GTN 625 NAVIGATOR 011-02254-00 6.00 27.73 166.38 -10.36 -62.16
2 GTN 635 NAVIGATOR 011-02255-00 6.80 27.73 188.56 -10.36 -70.45
3 GTN 650 NAVIGATOR 011-02256-00 7.60 27.73 210.75 -10.36 -78.74
4 GTN 725 NAVIGATOR 011-02281-00 8.60 38.72 332.99 -11.50 -98.90
5 GTN 750 NAVIGATOR 011-02282-00 10.20 38.72 394.94 -11.50 -117.30
6 011-02299-00 2.20 36.03 79.27 -11.50 -25.30
7 GMA 35 AUDIO PANEL 011-02299-20 2.10 36.03 75.66 -11.50 -24.15
8 011-02299-40 2.10 36.03 75.66 -11.50 -24.15
9 FLIGHT STREAM 510 011-03595-00 Neg n/a n/a n/a n/a
Table 8 Typical Weight and Balance of GTN and GMA 35 Installed in EC130B4
WEIGHT LONGITUDINAL LATERAL
ITEM DESCRIPTION PART NUMBER
[LB] ARM [IN] MOMENT ARM [IN] MOMENT
INSTRUMENT PANEL LOCATION
1 GTN 625 NAVIGATOR 011-02254-00 6.00 28.70 172.20 -10.42 -62.52
2 GTN 635 NAVIGATOR 011-02255-00 6.80 28.70 195.16 -10.42 -70.86
3 GTN 650 NAVIGATOR 011-02256-00 7.60 28.70 218.12 -10.42 -79.19
CONSOLE LOCATION
1 GTN 625 NAVIGATOR 011-02254-00 6.00 36.58 219.48 -11.69 -70.14
2 GTN 635 NAVIGATOR 011-02255-00 6.80 36.58 248.74 -11.69 -79.49
3 GTN 650 NAVIGATOR 011-02256-00 7.60 36.58 278.01 -11.69 -91.18
2.10 Diagrams
Aircraft specific LRU locations and wire routing diagram forms are contained in Appendix A of this
document. Completed forms are to be retained with the aircraft permanent records.
Point-to-point wiring diagrams for the GTN, GMA 35, and interfaced equipment included with the aircraft
permanent records.
GTN and GMA 35 locations are described in Section 2.8 of this document.