Professional Documents
Culture Documents
Description For Diff. Pressure Transmitter: Cargo
Description For Diff. Pressure Transmitter: Cargo
PRESSURE TRANSMITTER
Cargo Sheet No. Cargo-( 7 / 8) For Working
2. Zero Trim
First, please make a
Figure
zeroC-2.
trimRosemount 2051 Field Communicator menu tree: Configure - Guided Setup
Device Tagging
1) closed valve(High, 1 Tag
2 Long Tag
Low side on pipe) 3 Description
4 Message
5 Date
2) open the vent 3way
manifold Basic Setup
1 Device Tagging
Units of Measure/Damping
1 Units of Measure
Units of Measure
1 Pressure
2 Units of Measure/Damping 2 Damping 2 Sensor Temp Units
valve(importance) which 3 Variable Mapping
Variable Mapping
4 Analog Output
make a equalizing 5 Alarm/Saturation Values 1 Primary Variable
2 Second Variable
3 Third Variable
pressure between ATM 4 Fourth Variable
Selections with black circle are only available in HART Revision 7 mode. Selection will not appear in HART Revision 5 DD.
6. SV Low Cutoff
1) checked a low
cutoff value previous
setting and then put
a low cutoff value as
from 0.5mbar to
7.5mbar with 475
Hart communicator
and then check a
result.
4. HART Revision 5 and 7 Selectable, Safety Certified, Local Operator Interface, Scaled Variable, Configurable Alarms,
Expanded Engineering Units.
connecting 475
2.4 Configuration basics
Hart communicator
Set all transmitter hardware adjustments during commissioning to avoid exposing the transmitter
electronics to the plant environment after installation.
The Rosemount 2051 can be configured either before or after installation. Configuring the transmitter
on the bench using either a Field Communicator, AMS Device Manager, or LOI ensures all transmitter
components are in working order prior to installation. Verify that the security switch is set in the unlock
position ( ) in order to proceed with configuration. See Figure 4-2 on page 51 for switch location.
A. Vdc supply
B. RL 250 (necessary for HART communication only)
Configuration 9
Configuration Reference Manual
July 2017 00809-0100-4107, Rev CA
A. DC power supply
B. Voltmeter
2051 FT 45B
Online
1. Overview
2. Configure
3. Service Tools
SAVE
Note
All steps using AMS Device Manager will be described using version 11.5.
10 Configuration
How to make a "Zero Trim" with 3way manifold valve
D.P FLOWMETER COMMISSIONING TEST PROCEDURE
Date : 2013. Feb. Page : 10 / 10
9. Calibration
9.1 Zero Trim setting
9.2 Zero Setting precedure
9.2.1 Block v/v (3way~5way) ISOLATE V/V(PROCESS, High/Low) CLOSED → EQUALIZE (High/Low) OPEN → VENT V/V OPEN
9.2.2 Please make sure DPT should be equilized pressure between ATM and DPT inside and then make a “zero trim”