Download as docx, pdf, or txt
Download as docx, pdf, or txt
You are on page 1of 8

ENetwork final

1.

Refer to the exhibit. Which diagram depicts the path through the network that is represented in the
output of thet ra c e rt command?

2. Which subnet mask will allow 2040 hosts per subnet on the IP network 10.0.0.0?

255.255.248.0

3.

Refer to the exhibit. A PC is communicating with another PC on a remote network. The two
networks are connected by three routers. Which action will help to identify the path between the
hosts?

Use thet ra c e rt command at the host


4.

Refer to the exhibit. An administrator made several changes to the configuration of the router but did
not accomplish the desired result. To undo the changes the re l o a d command was used. What
will happen if the administrator answersy e s to the prompt?

The changes will be saved and the configuration file in NVRAM will be loaded.
5.

Refer to the exhibit. What two facts can be determined about the exhibited topology? (Choose two.)
A single broadcast domain is present
Five collision domains exist.
6. Which option shows how a router will route packets to a remote network?

7. What is true regarding network layer addressing? (Choose three.)

heirarchical
uniquely identifies each host
contains a network portion

8. A network has grown too large for technicians to configure network addresses and hosts files for
name resolution. Which two application layer services should be added to the server to allow
these needs to be satisfied dynamically? (Choose two.)
DNS
DHCP
9. A user sees the command prompt: Router(config-if)# . What task can be performed at this
mode?
Configure individual interfaces

10. A user enters http://www.cisco.com/web1.htm in the address line of a browser. Which statement
is true about this transaction?
The "http" portion indicates the protocol that is being used.

11. What is the Cisco IOS?

system software for Cisco devices

12.

Refer to the exhibit. Communication for hosts X and Y is restricted to the local network. What is the
reason for this?

The gateway addresses are broadcast addresses

13. Which OSI layer offers ordered data reconstruction services?

transport layer

14.

Refer to the exhibit. A student has wired each end of a CAT 5e cable as shown. What is the
result? (Choose two.)
The cable is suitable for use as a Fast Ethernet crossover

The cable is suitable for use between two 100 Mbps Auto-MDIX capable switches
15. Which information is used by the router to determine the path between the source and
destination hosts?
the network portion of the IP address
16.

Refer to the exhibit. A network technician has made several changes to R1 since the configuration
has last been saved. The modified configuration did not produce the desired changes. The
technician wants to store a backup copy of the saved configuration on a TFTP server before
reloading. Which action will cause the unmodified data to be saved on the TFTP server?

17.

Refer to the exhibit. A network technician is trying to determine the correct IP address
configuration for Host A. What is a valid configuration for Host A?

IP address: 192.168.100.20; Subnet Mask: 255.255.255.240; Default Gateway: 192.168.100.17


18.

Refer to the exhibit. An employee wants to access the organization intranet from home. Which
intermediary device should be used to connect the organization intranet to the Internet to enable
this access?
router

19. Which table accurately associates the RFC 1918 private IP addresses with the correct network
mask?

20. Which two functions of the OSI model occur at layer two? (Choose two.)

physical addressing
media access control

21. A network administrator subnets the network 192.168.1.0/24 into four subnets. Which option
correctly addresses Router1 and host A into the second subnet created?

22. Which option shows the PDU that contains the Layer 3 source and destination addressing for
a packet?
23. Which OSI layer manages data segments?

transport layer

24. Which memory contents will change as a result of using the Router# erase startup-configc
om m and on a router?

NVRAM

25. Two routers are connected via their serial ports in a lab environment. The routers are
configured with valid IP addresses, but they cannot ping each other. The show interface serial0/0
command shows that the serial0/0 interface is up but the line protocol is down. What could be
the cause of this problem?
The clock rate command has not been entered on the DCE interface.

26. Which topology represents a collision-free environment?

27.

Refer to the exhibit. Which option shows the correct topology given the configuration of Router1?

28. A technician is setting up a workgroup for six users and wants to allow users to share files
without setting up a server. Which application layer protocol will provide for peer-to-peer file
sharing in a workgroup?
SMB
29.

Refer to the exhibit. Which option correctly identifies the network address, range of host
addresses, and the broadcast address for the network that contains host A?

30.

Refer to the exhibit. Which Layer 2 protocol could be used inside nework A and network C?
Ethernet

31. What are three characteristics of CSMA/CD? (Choose three.)

Devices listen to the media and transmit data only when they cannot detect another signal
on the media.
All devices on the media can hear all communications.
When a collision occurs, all devices stop transmitting for a randomly generated period of
time.
32.

Refer to the exhibit. Host A is unable to reach host B on the remote network. A technician
attempted to ping the local gateway and the ping was successful. To verify the host
configuration, the technician issued thei pconfig command. What is the likely cause of the
problem?
The default gateway on host A is incorrectly configured

33. An organization has been assigned network ID 10.10.128.0 and subnet mask 255.255.224.0.
Which IP address range can be used for this organization?
10.10.128.0 to 10.10.159.255

34.

Refer to the exhibit. A PC is connected to a network. Which action will verify that the PC can
communicate with its default gateway?

Use the ping 10.0.0.254 command

35. How can ARP be used to help document the network?


It can provide a list of physical addresses on the network .

36. Which device should be used for enabling a host to communicate with another host on a
different network?
router

You might also like