Download as pdf or txt
Download as pdf or txt
You are on page 1of 36

Engine

03 - Engine

CONTENTS

03A01 - Sisu engine - General

03B10 - SISU TIER 3 ENGINE - General

03B11 - SISU TIER 3 ENGINE - Removing and refitting

Massey Ferguson 8400 Contents - i


Engine

Contents - ii Massey Ferguson 8400


Sisu engine - General

03A01 - Sisu engine - General

CONTENTS

A . Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

B . Specifications and standards concerning fuel, oil and coolant . . . . . . . . . . . . . . . . . 3

C . Main characteristics . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

Massey Ferguson 8400 - Issue 1.b 03A01.1


Sisu engine - General

03A01.2 Massey Ferguson 8400 - Issue 1.b


Sisu engine - General

A . Introduction
This section only provides general information about
Sisu engines used on this tractor series.

B . Specifications and standards


concerning fuel, oil and coolant
The engines fitted on this tractor series comply with
standards concerning emissions imposed by the
authorities. (EU97/68/EC Stage 2 and EPA 40 CFR 89
Tier 2).
The quality of fluids used in these engines as well as
the servicing schedule must be respected in order to
keep pollution emission levels low and to maintain the
tractor good performance during its whole life.

Fuel quality:
The fuel must comply with standard DIN EN 590 and
with the following specifications:
Density (at 15°C): 0.82 to 0.84 Kg/dm3
Viscosity (at 40°C): 2 to 4.5 mm2/s
Cetane index: min. 51
Sulphur content: max. 0.005 p-%
Water content: max. 200 mg/kg

Oil quality:
The oil used must comply with standard API CH-4.

Coolant quality:
The coolant used must comply with standard
ASTM D 3306. It must be composed of pure water
and ethylene/propylene glycol antifreeze agent in the
following proportions:
40 - 60% water
40 - 60% antifreeze agent
The ideal ratio is 50% water to 50% antifreeze agent.

Massey Ferguson 8400 - Issue 1.b 03A01.3


Sisu engine - General

C . Main characteristics

Model 8450
Engine type SISU 74 ETA
Number of cylinders 6
Bore 108
Stroke 134
Capacity 7.4
Compression ratio 17.5/1
Compression pressure (kPa) 2000 / 3500
Allowable compression deviation between cylinders (kPa) 350
Output at 2,200 rpm ch (kw) ISO 215 (158)
Maximum torque (Nm) 925
at speed (rpm) 1500
Idle speed 800
Nominal speed 2200
Maximum speed at no load 2350
Pre- / Post-heating yes
Wet cylinder sleeves yes
Weight (kg) 520
Injection pump
Trademark and type Bosch VP44
Rotation Clockwise
Static timing angle (degrees) 26°
Engine position TDC
Engine check angle (degrees) pin
Injection order 1-5-3-6-2-4
Lift pump Electric
Injectors
Trademark Stanadyne
Code M33877
Nozzle holder
Nozzle 5 ports
New and servicing setting (bar) 278
Miscellaneous
Suction system Intercooler air/air turbocompressor
(no wastegate)
Minimum boost pressure at 2,200 rpm at full load (bar) 1.2
Number of valves per cylinder 2
Valve spring simple
Valve seat insert (Inlet / Exhaust) yes / yes
Inlet / Exhaust valve angle 35° / 45°
Inlet / Exhaust valve tip clearance (mm) 0.35 / 0.35
Oil cooler yes
Number of temperature switches 2
Opening temperature (start/full) 83°C
Fan Vistronic
Piston cooling nozzle yes
Oil filter 1
Fuel filter (microns) prefilter (30) + filter (5)

03A01.4 Massey Ferguson 8400 - Issue 1.b


Sisu engine - General

Model 8460
Engine type SISU 74 ETA
Number of cylinders 6
Bore 108
Stroke 134
Capacity 7.4
Compression ratio 17.5/1
Compression pressure (kPa) 2000 / 3500
Allowable compression deviation between cylinders (kPa) 350
Output at 2,200 rpm ch (kw) ISO 235 (173)
Maximum torque (Nm) 990
at speed (rpm) 1500
Idle speed 800
Nominal speed 2200
Maximum speed at no load 2350
Pre- / Post-heating yes
Wet cylinder sleeves yes
Weight (kg) 520
Injection pump
Trademark and type Bosch VP44
Rotation Clockwise
Static timing angle (degrees) 26°
Engine position TDC
Engine check angle (degrees) pin
Injection order 1-5-3-6-2-4
Lift pump Electric
Injectors
Trademark Stanadyne
Code M33877
Nozzle holder
Nozzle 5 ports
New and servicing setting (bar) 278
Miscellaneous
Suction system Intercooler air/air turbocompressor
(no wastegate)
Minimum boost pressure at 2,200 rpm at full load (bar) 1.3
Number of valves per cylinder 2
Valve spring simple
Valve seat insert (Inlet / Exhaust) yes / yes
Inlet / Exhaust valve angle 35° / 45°
Inlet / Exhaust valve tip clearance (mm) 0.35 / 0.35
Oil cooler yes
Number of temperature switches 2
Opening temperature (start/full) 83°C
Fan Vistronic
Piston cooling nozzle yes
Oil filter 1
Fuel filter (microns) prefilter (30) + filter (5)

Massey Ferguson 8400 - Issue 1.b 03A01.5


Sisu engine - General

Model 8470
Engine type SISU 84 ETA
Number of cylinders 6
Bore 111
Stroke 145
Capacity 8.4
Compression ratio 17.5/1
Compression pressure (kPa) 2000 / 3500
Allowable compression deviation between cylinders (kPa) 350
Output at 2,200 rpm ch (kw) ISO 260 (191)
Maximum torque (Nm) 925
at speed (rpm) 1100
Idle speed 800
Nominal speed 2200
Maximum speed at no load 2350
Pre- / Post-heating yes
Wet cylinder sleeves yes
Weight (kg) 660
Injection pump
Trademark and type Bosch VP44
Rotation Clockwise
Static timing angle (degrees) 28°
Engine position TDC
Engine check angle (degrees) pin
Injection order 1-5-3-6-2-4
Lift pump Electric
Injectors
Trademark Stanadyne
Code M33877
Nozzle holder
Nozzle 5 ports
New and servicing setting (bar) 278
Miscellaneous
Suction system Intercooler air/air turbocompressor
(no wastegate)
Minimum boost pressure at 2,200 rpm at full load (bar) 1.1
Number of valves per cylinder 2
Valve spring simple
Valve seat insert (Inlet / Exhaust) yes / yes
Inlet / Exhaust valve angle 35° / 45°
Inlet / Exhaust valve tip clearance (mm) 0.35 / 0.35
Oil cooler yes
Number of temperature switches 2
Opening temperature (start/full) 83°C
Fan Vistronic
Piston cooling nozzle yes
Oil filter 1
Fuel filter (microns) prefilter (30) + filter (5)

03A01.6 Massey Ferguson 8400 - Issue 1.b


Sisu engine - General

Model 8480
Engine type SISU 84 ETA
Number of cylinders 6
Bore 111
Stroke 145
Capacity 8.4
Compression ratio 17.5/1
Compression pressure (kPa) 2000 / 3500
Allowable compression deviation between cylinders (kPa) 350
Output at 2,200 rpm ch (kw) ISO 290 (213)
Maximum torque (Nm) 1190
at speed (rpm) 1500
Idle speed 800
Nominal speed 2200
Maximum speed at no load 2350
Pre- / Post-heating yes
Wet cylinder sleeves yes
Weight (kg) 660
Injection pump
Trademark and type Bosch VP44
Rotation Clockwise
Static timing angle (degrees) 28°
Engine position TDC
Engine check angle (degrees) pin
Injection order 1-5-3-6-2-4
Lift pump Electric
Injectors
Trademark Stanadyne
Code M33877
Nozzle holder
Nozzle 5 ports
New and servicing setting (bar) 278
Miscellaneous
Suction system Intercooler air/air turbocompressor
(no wastegate)
Minimum boost pressure at 2,200 rpm at full load (bar) 1.2
Number of valves per cylinder 2
Valve spring simple
Valve seat insert (Inlet / Exhaust) yes / yes
Inlet / Exhaust valve angle 35° / 45°
Inlet / Exhaust valve tip clearance (mm) 0.35 / 0.35
Oil cooler yes
Number of temperature switches 2
Opening temperature (start/full) 83°C
Fan Vistronic
Piston cooling nozzle yes
Oil filter 1
Fuel filter (microns) prefilter (30) + filter (5)

Massey Ferguson 8400 - Issue 1.b 03A01.7


Sisu engine - General

03A01.8 Massey Ferguson 8400 - Issue 1.b


SISU TIER 3 ENGINE - General

03B10 - SISU TIER 3 ENGINE - General

CONTENTS

A . Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

B . Specifications and standards concerning fuel, oil and coolant . . . . . . . . . . . . . . . . . 3

C . Main specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

Massey Ferguson 8400 - Issue 3.a 03B10.1


SISU TIER 3 ENGINE - General

03B10.2 Massey Ferguson 8400 - Issue 3.a


SISU TIER 3 ENGINE - General

A . Introduction
This section only provides general information about
Sisu engines used in this tractor range.

B . Specifications and standards


concerning fuel, oil and coolant
The quality of fluids used in these engines, as well as
the servicing schedule, must be respected to keep
pollution emission levels low and to maintain the
tractor's performance throughout its service life.

Fuel quality
The fuel must comply with standard DIN EN 590
and with the following specifications:
Density (at 15°C): 0.82 to 0.86 kg/dm3
Viscosity (at 40°C): 2 to 4.5 mm²/sec
Cetane Index: min 45
Sulphur content: max 0.20% of weight
Water content: max 200 mg/kg

Oil quality
The oil used must comply with standard API CI-4.

Coolant quality
The coolant used must comply with standard
BS 6580-1992. It should be a permanent, ethylene/
glycol type coolant.

Massey Ferguson 8400 - Issue 3.a 03B10.3


SISU TIER 3 ENGINE - General

C . Main specifications

Model 8450
Engine type SISU 74 CTA
Number of cylinders 6
Bore 108
Stroke 134
Cubic capacity 7.4
Compression ratio N/A
Compression pressure (kPa) N/A
Permissible compression deviation between cylinders (kPa) N/A
Output at 2200 rpm (kw) ISO 167
Maximum torque (Nm) 970
at speed (rpm) 1500
Idle speed 800
Nominal speed 2200
Maximum speed at no load 2250
Pre-/Post-heating YES
Wet liners YES
Weight (kg) 525
Injection pump
Brand and type Bosch CP3.3
Rotation Clockwise
Static timing angle (degrees) N/A
Engine position N/A
Engine check angle (degrees) N/A
Firing order 1, 5, 3, 6, 2, 4
Fuel lift pump Electric
Injectors
Brand Bosch
New and servicing setting (bar) N/A
Miscellaneous
Aspiration system Intercooler air/air turbocompressor
(no wastegate)
Number of valves per cylinder 4
Valve spring simple
Valve seat insert (inlet/exhaust) yes
Valve angle N/A
Inlet/exhaust valve tip clearance (mm) 0.35/0.35
Oil cooler yes
Number of temperature switches 1
Opening temperature (start/full) 79°C/93°C
Piston cooling nozzle yes
Oil filter 1
Fuel filter Prefilter (30µ) + filter (5µ)
Number of temperature switches 2
Opening temperature (start/full) 83°C/93°C
Fan Vistronic
Piston cooling nozzle yes
Lubrication system Gear pump

03B10.4 Massey Ferguson 8400 - Issue 3.a


SISU TIER 3 ENGINE - General

Model 8460
Engine type SISU 74 CTA
Number of cylinders 6
Bore 108
Stroke 134
Cubic capacity 7.4
Compression ratio N/A
Compression pressure (kPa) N/A
Permissible compression deviation between cylinders (kPa) N/A
Output at 2200 rpm (kw) ISO 178.5
Maximum torque (Nm) 1071
at speed (rpm) 1500
Idle speed 800
Nominal speed 2200
Maximum speed at no load 2250
Pre-/Post-heating YES
Wet liners YES
Weight (kg) 525
Injection pump
Brand and type Bosch CP3.3
Rotation Clockwise
Static timing angle (degrees) N/A
Engine position N/A
Engine check angle (degrees) N/A
Firing order 1, 5, 3, 6, 2, 4
Fuel lift pump Electric
Injectors
Brand Bosch
New and servicing setting (bar) N/A
Miscellaneous
Aspiration system Intercooler air/air turbocompressor
(no wastegate)
Number of valves per cylinder 4
Valve spring simple
Valve seat insert (inlet/exhaust) yes
Valve angle N/A
Inlet/exhaust valve tip clearance (mm) 0.35/0.35
Oil cooler yes
Number of temperature switches 1
Opening temperature (start/full) 79°C/93°C
Piston cooling nozzle yes
Oil filter 1
Fuel filter Prefilter (30µ) + filter (5µ)
Number of temperature switches 2
Opening temperature (start/full) 83°C/93°C
Fan Vistronic
Piston cooling nozzle yes
Lubrication system Gear pump

Massey Ferguson 8400 - Issue 3.a 03B10.5


SISU TIER 3 ENGINE - General

Model 8470
Engine type SISU 84 CTA
Number of cylinders 6
Bore 111
Stroke 145
Cubic capacity 8.4
Compression ratio N/A
Compression pressure (kPa) N/A
Permissible compression deviation between cylinders (kPa) N/A
Output at 2200 rpm (kw) ISO 197
Maximum torque (Nm) 1195
at speed (rpm) 1500
Idle speed 800
Nominal speed 2200
Maximum speed at no load 2250
Pre-/Post-heating YES
Wet liners YES
Weight (kg) 650
Injection pump
Brand and type Bosch CP3.3
Rotation Clockwise
Static timing angle (degrees) N/A
Engine position N/A
Engine check angle (degrees) N/A
Firing order 1, 5, 3, 6, 2, 4
Fuel lift pump Electric
Injectors
Brand Bosch
New and servicing setting (bar) N/A
Miscellaneous
Aspiration system Intercooler air/air turbocompressor
(no wastegate)
Number of valves per cylinder 4
Valve spring simple
Valve seat insert (inlet/exhaust) yes
Valve angle N/A
Inlet/exhaust valve tip clearance (mm) 0.35/0.35
Oil cooler yes
Number of temperature switches 1
Opening temperature (start/full) 83°C/93°C
Piston cooling nozzle yes

03B10.6 Massey Ferguson 8400 - Issue 3.a


SISU TIER 3 ENGINE - General

Model 8480
Engine type SISU 84 CTA
Number of cylinders 6
Bore 111
Stroke 145
Cubic capacity 8.4
Compression ratio N/A
Compression pressure (kPa) N/A
Permissible compression deviation between cylinders (kPa) N/A
Output at 2200 rpm (kw) ISO 216
Maximum torque (Nm) 1280
at speed (rpm) 1500
Idle speed 800
Nominal speed 2200
Maximum speed at no load 2250
Pre-/Post-heating YES
Wet liners YES
Weight (kg) 650
Injection pump
Brand and type Bosch CP3.3
Rotation Clockwise
Static timing angle (degrees) N/A
Engine position N/A
Engine check angle (degrees) N/A
Firing order 1, 5, 3, 6, 2, 4
Fuel lift pump Electric
Injectors
Brand Bosch
New and servicing setting (bar) N/A
Miscellaneous
Aspiration system Intercooler air/air turbocompressor
(no wastegate)
Number of valves per cylinder 4
Valve spring simple
Valve seat insert (inlet/exhaust) yes
Valve angle N/A
Inlet/exhaust valve tip clearance (mm) 0.35/0.35
Oil cooler yes
Number of temperature switches 1
Opening temperature (start/full) 83°C/93°C
Piston cooling nozzle yes

Massey Ferguson 8400 - Issue 3.a 03B10.7


SISU TIER 3 ENGINE - General

03B10.8 Massey Ferguson 8400 - Issue 3.a


SISU TIER 3 ENGINE - Removing and refitting

03B11 - SISU TIER 3 ENGINE - Removing and refitting

CONTENTS

A . Checking the valve timing adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

B . Removing and refitting an injector . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6

C . Removing and refitting the high pressure pump (Fig. 17) . . . . . . . . . . . . . . . . . . . . 11

D . Checking and adjusting the valve tip clearance (Fig. 18) . . . . . . . . . . . . . . . . . . . . . 13

E . Description of the EEM. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14

Massey Ferguson 8400 - Issue 3.a 03B11.1


SISU TIER 3 ENGINE - Removing and refitting

03B11.2 Massey Ferguson 8400 - Issue 3.a


SISU TIER 3 ENGINE - Removing and refitting

A . Checking the valve timing adjust-


ment
1
Checking the valve timing adjustment
3
NOTE: The engine oil must be drained before opening
the timing housing. Use a new seal for the cover of the
timing housing. 2

4
1. Remove the fan, the belt (1), the alternator (2) and
the air conditioning compressor if the tractor has
air conditioning. 5
2. Remove the crankshaft pulley (3) and the damper (4).
3. Unscrew the crankshaft nut (5) by two turns,
without actually removing it (service tool
ref. 902455800). MA-03-04006A

NOTE: The nut will serve as a retainer when Fig. 1


removing the hub.
4. Fit the extracting tool (service tool ref. 910453300)
onto the crankshaft hub and extract the hub
(Fig. 2).
5. Take off the extracting tool, remove the crankshaft
nut and remove the hub.
6. On 84CTA engines, remove the water pump
screws and mark them.
7. Remove the screws from the timing cover and the
belt tensioner (19 screws for 74CTA engines, 910453300
22 screws for 84CTA engines).
NOTE: Mark the long screws and the short screws,
and their locations.
8. Turn the crankshaft pinion in the direction that the
engine turns, until the mark of the crankshaft
pinion is lined up with that of the intermediary
pinion.
IMPORTANT: Do not force if it blocks during rotation. MA-03-04007A
Fig. 2

Massey Ferguson 8400 - Issue 3.a 03B11.3


SISU TIER 3 ENGINE - Removing and refitting

9. The marks of the intermediary pinion must be lined


up with those of the camshaft and the crankshaft
(Fig. 3). If the marks do not line up, proceed as
follows:
10. Remove the intermediary pinion (2) (Fig. 3).
11. Turn the crankshaft (3) (Fig. 3) to move the pinion
mark vertically; in this position, the cylinder piston
n° 1(timing side) should be at top dead centre
(TDC).
12. Turn the camshaft to bring the valves of cylinder
n° 6 (engine flywheel side) to the "rock" position,
i.e. to the point when the exhaust valves close, and
the inlet valves open.
13. Then fit the intermediary pinion so that the marks
are lined up (Fig. 3).
NOTE: It may be necessary to turn the crankshaft
slightly to line up the marks correctly.
Fig. 3
14. Fit the oil pipe washer.
NOTE: Pay close attention to the way it is fitted,
see Fig. 4.
15. Fit the centring tool onto the timing housing.

Engine type Tool ref


74CTA 920130270 (Fig. 5)
84CTA 920130290 (Fig. 6)

16. Fit the centring screws of the tool on the interme-


diary pinion.
17. Tighten the nuts of the intermediary pinion to the
corresponding torque:

M14 : 180 Nm
M8 : 45 Nm

Fig. 4

18. Remove the centring tool.


19. Check the backlash. Value: 920130270
0.05 to 0.25 mm
20. Fit a new cover seal.
21. Fit the cover, making sure that the centring pins
are located properly.
22. Fit the cover screws but do not tighten them.

MA-03-04011A

Fig. 5

03B11.4 Massey Ferguson 8400 - Issue 3.a


SISU TIER 3 ENGINE - Removing and refitting

23. Using service tool 910394600, fit a new seal on the


crankshaft (Fig. 7).
24. Grease the seal, the threads of the crankshaft and 920130290
the hub.
25. Fit the crankshaft hub.
26. Fit the crankshaft nut and tighten it to the corre-
sponding torque:

1000 Nm

27. Tighten the nuts on the timing cover. MA-03-04010A


28. Refit the components removed as indicated at the Fig. 6
start of the paragraph.
29. Add the engine oil and check the level.

910394600
MA-03-04012A
Fig. 7

Massey Ferguson 8400 - Issue 3.a 03B11.5


SISU TIER 3 ENGINE - Removing and refitting

Schematic diagram of the common rail direct


B . Removing and refitting an injector injection system
NOTE: This chapter is a general guide to the repair of (1) Tank
certain components of the injection system, such as (2) Electrical suction pump
the replacement of an injector, the replacement of the (3) 30 µ prefilter
injection common rail or the high-pressure pump. (4) Water filter
These operations must be carried out by qualified (5) 5 µ main filter
persons equipped with specific tools. (6) Temperature sensor
IMPORTANT: The components must be perfectly clean (7) Pressure sensor
during any servicing operations on the injection (8) High-pressure pump
system. (9) Common rail
All the pipes that are removed must be blocked off. (10) Overpressure valve
(11) Injector
(12) Common rail pressure sensor

10

11
2

12
6 3

4
7 5
8

MA-03-04013A
Fig. 8

03B11.6 Massey Ferguson 8400 - Issue 3.a


SISU TIER 3 ENGINE - Removing and refitting

Operation of the fuel circuit


The electric pump (2) draws up the fuel through
the prefilter (3) and delivers it to the main filter (5).
The high-pressure pump (8) uses its booster pump to
draw the fuel from the main filter and delivers it at high
pressure (approx. 1200 bar) into the common rail (9).
The calculator controls each injector (11) independ-
ently and thus allows fuel injection in the cylinder at a
precise point in the engine cycle. Excess fuel returns
to the fuel tank through the return pipes.

Massey Ferguson 8400 - Issue 3.a 03B11.7


SISU TIER 3 ENGINE - Removing and refitting

Removing an injector

DANGER: Never open the high-pressure


circuit with the engine running. Fuel under pressure
can penetrate the skin or eyes and cause serious
personal injury, blindness or death. Contact a
doctor urgently in the event of an accident. Wait at
least 30 seconds after turning the engine off before
any servicing.

30. Clean all around the injectors and pipes.


31. Remove the cylinder head cover.
32. Remove the protective cap and take out
the contact nuts (1) (Fig. 9), then disconnect the
electrical connections.
Fig. 9

33. Remove the injector supply pipe, and remove the


nut (6) (Fig. 10) from the high-pressure supply pipe.

Fig. 10

34. Remove the high-pressure supply pipe (5) (Fig. 11).

Fig. 11

03B11.8 Massey Ferguson 8400 - Issue 3.a


SISU TIER 3 ENGINE - Removing and refitting

35. Remove the screw (2), the washer (3) and the
flange (4).

IMPORTANT: The injectors and the supply pipes are cali-


brated together. Do not mix up the different pipes and
injectors during removal.

Fig. 12

36. Take out the injector and the flange. If it is not


stuck on the injector, remove the seal ring (7)
(Fig. 14).
Clean all components.

Refitting an injector
NOTE: A new high-pressure pipe must be fitted
between the injector and the common rail to avoid any
leaks.

37. Clean the injector seat on the cylinder head.


Fit a new seal ring and a new "O" ring.
Fig. 13
38. Fit the injector in its housing.
Fit the high-pressure supply pipe (5), in the correct
direction (see arrow, Fig. 14)
39. Tighten the screws following the steps below:
- Pre-tighten the screw (2) to a torque of: 2

1 3
15 Nm
4

7 5

MA-03-04014A

Fig. 14

Massey Ferguson 8400 - Issue 3.a 03B11.9


SISU TIER 3 ENGINE - Removing and refitting

40. Unscrew the screw (2) (Fig. 15) and pre-tighten the
nut (6) to a torque of:
9
15 Nm 2

41. Tighten the screw (2) (Fig. 15) to a torque of:


6
40 Nm

42. Tighten the nut (6) (Fig. 15) to a torque of:


MA-03-04015A

50 Nm Fig. 15

11 10
43. Fit a new high-pressure pipe (8) (Fig. 15) between
the injector and the common rail, and tighten the
union to a torque of:

30 Nm

44. Refit the electrical power supplies (9) (Fig. 15), and
tighten M4 nuts to a torque of:

1.5 Nm
MA-03-04016A
Fig. 16

45. Refit the protective cap onto the injector.


46. Refit the cylinder head cover (11) (Fig. 16), using a
new seal.
47. Tighten the screws (10) (Fig. 16) of the cylinder
head cover to a torque of:

25 Nm

48. Check again that there are no leaks in the


high-pressure circuit.

03B11.10 Massey Ferguson 8400 - Issue 3.a


SISU TIER 3 ENGINE - Removing and refitting

C . Removing and refitting the high


pressure pump (Fig. 17) 1
4 2

6
DANGER: Never open the high-pressure
circuit with the engine running. Fuel under pressure 5
can penetrate the skin or eyes and cause serious 3
personal injury, blindness or death. Contact a
doctor urgently in the event of an accident. Wait at
least 30 seconds after turning the engine off before
any servicing.

Removal
49. Clean all around the pump and the high-pressure
unions. Fig. 17
50. Disconnect the electrical connector (1).
51. Remove the fuel pipes, and block their ends (2).
52. Remove the 3 screws from the pump (3).
53. Remove the high-pressure pump (4).
54. Use an extracting tool to remove the pinion (5).

Refitting
55. Fit a new "O" ring (6).
56. If the timing cover has not been removed, fit the
pinion (5) onto the new pump. If the timing cover
has been removed, the pinion may be fitted by the
timing housing.
57. Fit and tighten the pinion fastening nut (5) of the
pump to the corresponding torque:

105 Nm

58. Grease the "O" ring (6), and fit the high-pressure
pump (4) in its location.

Massey Ferguson 8400 - Issue 3.a 03B11.11


SISU TIER 3 ENGINE - Removing and refitting

59. Fit and tighten the screws (3) to a torque of:

30 Nm

NOTE: There is no setting mark on the pinion of the


high-pressure pump; the position of the pinion is free
in relation to the other timing pinions.
60. Fit the fuel pipes and tighten the unions to the
corresponding torques:
- Low pressure

25 Nm

- High pressure

30 Nm

61. Refit the electrical connector (1).

03B11.12 Massey Ferguson 8400 - Issue 3.a


SISU TIER 3 ENGINE - Removing and refitting

D . Checking and adjusting the valve


tip clearance (Fig. 18) 11 10

NOTE: It is advisable to change the seal of the cylinder


head cover during this operation.

62. Remove the screws (10).


63. Remove the cylinder head cover (11).
64. Turn the crankshaft to bring the valves of cylinder
n° 6 to the rock position (Fig. 19).
65. On cylinder n° 1 (Fig. 19), unscrew the locknut of
the inlet valve adjusting screw.
66. Using a thickness shim, check the clearance
between the valve tip and the rod of the inlet valve
(1) (Fig. 20) using the screw to adjust if necessary.
MA-03-04016A
67. Tighten the locknut then check the clearance Fig. 18
again. Repeat the previous operation if necessary,
until the correct value is attained.
68. Then carry out the same procedure for the exhaust
valve of cylinder n° 1(2) (Fig. 20)
69. Turn the crankshaft about 1/3 of a turn in the direction
of the engine, then bring the valves of cylinder n° 2 to
the rock position. Then carry out the same operations
on cylinder n° 5. 1 2 3 4 5 6
70. Carry out the same procedure for the other cylin-
ders, referring to the table below to start the
adjustment:

Firing order 1 5 3 6 2 4
Valves on the rock on cyl. n° 6 2 4 1 5 3

71. Refit the cylinder head cover using a new seal. MA-03-04019A
72. Tighten the screws (10) (Fig. 18) to a torque of:
Fig. 19

25 Nm

3 0.35 mm

0.35

MA-03-04018A

Fig. 20

Massey Ferguson 8400 - Issue 3.a 03B11.13


SISU TIER 3 ENGINE - Removing and refitting

E . Description of the EEM


General

Fig. 21

1 Temperature and air pressure sensor 8 Calculator


2 Injectors 9 Identification module
3 Heater 10 Oil pressure sensor
4 Fuel pressure sensor 11 High-pressure pump
5 Electric fuel pump 12 Injection common rail and high-pressure sensor
6 Fuel temperature sensor 13 Camshaft sensor
7 Engine flywheel sensor 14 Water temperature sensor

03B11.14 Massey Ferguson 8400 - Issue 3.a


SISU TIER 3 ENGINE - Removing and refitting

Details on the different components


Temperature and air pressure sensor
This sensor constantly measures the temperature and
the air pressure in the inlet manifold. It is supplied with
5 V direct current. It is located on the air inlet manifold.

Temperature
The resistance of the sensor decreases as temperature
rises.
Nominal resistance:
- at 20°C = 2.5 kΩ
- at 100°C = 0.186 kΩ

Pressure
Output voltage:
- at 100 kPa (around air pressure) = 1.07 V MA-03-04021A
Fig. 22
- at 200 kPa = 2.21 V

Injector
Current required for opening 25 A
Current required to keep open 12 A
Delivery pressure from 0 to 10 bar
8-hole injector

MA-03-04022A

Fig. 23

Fuel pressure sensor


This sensor constantly measures the absolute pressure
in the supply line of fuel coming from the tank. It is
supplied with 5 V direct current. It is located on the main
fuel filter.
Output voltage:
- at 0 kPa = 0.5 V
- at 360 kPa = 4.9 V (absolute pressure)

Fig. 24

Massey Ferguson 8400 - Issue 3.a 03B11.15


SISU TIER 3 ENGINE - Removing and refitting

Fuel temperature sensor


This sensor measures the temperature of the fuel in
the supply line coming from the tank. It is supplied
with 5 V direct current. It is located on the main fuel
filter. The resistance of the sensor decreases as
temperature rises.
Nominal resistance values:
- at 20°C = 2.5 kΩ
- at 100°C = 0.186 kΩ

Fig. 25

Engine flywheel sensor


This sensor is inductive. It detects each tooth on the
engine flywheel (one tooth every 3°) and transmits
alternating current to the calculator. If this sensor fails,
the camshaft sensor allows the engine to continue to
run. Power will, however, be reduced.

Fig. 26

Calculator
12 V supply, but will accept 24 V. This calculator is
fitted with an internal digital sensor for atmospheric air
pressure.

Fig. 27

03B11.16 Massey Ferguson 8400 - Issue 3.a


SISU TIER 3 ENGINE - Removing and refitting

Identification module
This module is fitted onto the left-hand side of the
engine block and cannot be removed. It ensures
optimal operation during the replacement of the EEM.

Fig. 28

Oil pressure sensor


This sensor constantly measures the absolute pressure
of the engine oil. It is supplied with 5 V direct current.
Output voltage:
- at 0 kPa = 0.5 V
- at 360 kPa = 4.5 V
It is located on the left-hand side of the engine block.

Fig. 29

High-pressure sensor on the injection


common rail
This sensor measures the pressure in the common rail
in relation to the atmospheric air pressure. It is
supplied with 5 V direct current. It is located at the end
of the injection common rail, towards the front-end of
the engine.
Output voltage:
- at 0 MPa = 0.5 V
- at 31,800 kMPa = 4.5 V

Fig. 30

Massey Ferguson 8400 - Issue 3.a 03B11.17


SISU TIER 3 ENGINE - Removing and refitting

Camshaft sensor
This sensor transmits a signal at each rotation of the
camshaft, indicating the point of injection. The camshaft
pulley has 7 teeth, 1 for each cylinder + 1 for the top
dead centre (TDC) of cylinder n° 1. It is located on the
timing housing, just above the camshaft pinion.
If this sensor fails, the engine will continue to run, but at
reduced power.

Fig. 31

Water temperature sensor


This sensor measures the temperature of the coolant.
It is supplied with 5 V direct current. It is situated on
the top of the cylinder head. The resistance of the
sensor decreases as temperature rises.
Nominal resistance values:
- at 20°C = 2.5 kΩ
- at 100°C = 0.186 kΩ

Fig. 32

03B11.18 Massey Ferguson 8400 - Issue 3.a

You might also like