Rac vee
KALPATARU INSTITUTE OF TECHNOLOGY -TIPTUR
Department of Mechanical Engineering
Fifth Semester BLE. Degree Flrst Test, Sept -2016
Design of Machine Elements
Time :2.30-4pm Date: 21/09/2016
Duration: 1 brs. Max. Marks: 50
Note: 1. Answ or any THREE fall questions, selecting TWO questions. from PARTAA &
ONE question rom PART-B
2. Usage of desig dau uandbook is permitied and missing data may be suitably assumed
PART-A POs
1 a Define any 6 ofthe following: i, Ductility ii, Toughness iii. Hardness iv. Stifness 06 Marks |
¥. Resilience vi. Creep vi. lastcity
1b A point in a structural member subject to plane stress is shown in Fig. 1. Determine 10 Marks |,
magnitide of siresses rial points
PART-B
4 a Whatis stress concentration? Lis the methods to
jgnte the tess concentration, 06 Marks | 7
'b A flat plate subjected to a tensile force of $ KN is shown in Fig. 4. The plate material 12 Marks |,
is grey cast iron having a, value of 200 MPa. Determine the thickness of the flat b.
plate, Factor of safety is 25. 6
5 a Explain the following Theor
i. Maximum shear stress theory
stortion energy theory
b A mild steel shaft of 60 mm diameter is subjected to a bending moment of 25*10° 12 Marks "a,
1N-mm and torque Mf the yield point of tension is 230 Nimm’, find the maximum b
value of this torque without causing yielding ofthe shaft aecording to ce
‘Maximum shear stress theory
Distortion energy theory
of Failure: (06 Marks |i,